基于YAG∶Ce3+荧光粉复合Eu3+掺杂荧光玻璃的激光照明器件

郑飞; 茅云蔚; 杨波波; 邹军; 刘祎明; 谢宇; 汤子睿; 库黎明; 邵鹏睿; 陈狄杰

doi:10.3788/fgxb20194007.0842

您当前的位置：

首页 >

文章列表页 >

基于YAG∶Ce³⁺荧光粉复合Eu³⁺掺杂荧光玻璃的激光照明器件

材料合成及性能 | 更新时间：2020-08-12

- 基于YAG∶Ce³⁺荧光粉复合Eu³⁺掺杂荧光玻璃的激光照明器件
- Laser Lighting Device Based on YAG: Ce³⁺ Phosphor Composite Eu³⁺ Doped Phosphor-in-glasses
- 发光学报 2019年40卷第7期页码：842-848
- 作者机构：
  
  1. 上海应用技术大学理学院, 上海 201418
  2. 上海应用技术大学材料科学与工程学院, 上海 201418
  3. 有研半导体材料有限公司, 北京 100088
  4. 深圳市晶台股份有限公司, 广东深圳 518105
  5. 浙江美科电器有限公司, 浙江绍兴 312000
- 作者简介：
- 基金信息：
  
  浙江省科技计划项目重点研发计划（2018C01046）();横向项目（激光植物灯）（J2017-243）资助()
- DOI：10.3788/fgxb20194007.0842
  中图分类号： TN365
- 纸质出版日期：2019-7-5，
  
  网络出版日期：2018-10-11，
  
  收稿日期：2018-7-17，
  
  修回日期：2018-9-22，
扫描看全文
郑飞, 茅云蔚, 杨波波等. 基于YAG∶Ce3+荧光粉复合Eu3+掺杂荧光玻璃的激光照明器件[J]. 发光学报, 2019,40(7): 842-848

ZHENG Fei, MAO Yun-wei, YANG Bo-bo etc. Laser Lighting Device Based on YAG: Ce3+ Phosphor Composite Eu3+ Doped Phosphor-in-glasses[J]. Chinese Journal of Luminescence, 2019,40(7): 842-848
郑飞, 茅云蔚, 杨波波等. 基于YAG∶Ce3+荧光粉复合Eu3+掺杂荧光玻璃的激光照明器件[J]. 发光学报, 2019,40(7): 842-848 DOI： 10.3788/fgxb20194007.0842.

ZHENG Fei, MAO Yun-wei, YANG Bo-bo etc. Laser Lighting Device Based on YAG: Ce3+ Phosphor Composite Eu3+ Doped Phosphor-in-glasses[J]. Chinese Journal of Luminescence, 2019,40(7): 842-848 DOI： 10.3788/fgxb20194007.0842.

摘要

采用结晶法和低温共烧结法制备了Eu

掺杂的Y

:Ce

荧光玻璃，对制备出的样品进行能量色散X射线谱和光致发光光谱测试，表明稀土离子Eu

与YAG:Ce

荧光粉已掺入荧光玻璃。掺杂不同含量Eu

的YAG:Ce

荧光玻璃封装成的激光照明器件在驱动电流100 mA下，经过STC-4000快速光谱仪和PMS-80可见光谱分析系统测试，掺杂质量分数1% YAG:Ce

复合质量分数9%的Eu

的荧光玻璃封装的激光照明器件发光效率为267.1 lm/W。激光照明器件随着电流的增加，其显色指数逐渐增大，但增加幅度较小。

Abstract

The Eu

doped Y

:Ce

phosphor-in-glasses(PIGs) was prepared by crystallization and low temperature co-sintering. The prepared samples were tested by energy dispersive X-ray and photoluminescence spectroscopy

indicating that the rare earth ions Eu

and YAG:Ce

phosphors have been incorporated into the PIG. YAG:Ce

PIG with different content of Eu

is packaged in a laser illumination device with a driving current of 100 mA. It is tested by STC-4000 fast spectrometer and PMS-80 visible spectrum analysis system

doping mass fraction 1% YAG:Ce

composite mass fraction 9% Eu

phosphor-in-glasses encapsulated laser lighting device luminous efficacy is 267.1 lm/W. As the current of laser illumination devices increases

the color rendering index increases gradually

but the increase is small.

关键词

结晶法低温共烧结法荧光玻璃激光照明器件

Keywords

crystallizationlow temperature co-sinteringphosphor-in-glasseslaser lighting device

references

TSAO J Y. Solid-state lighting:lamps,chips,and materials for tomorrow[J]. IEEE Circuits Devices Mag., 2004,20(3):28-37.

史光国. 半导体发光二级管及固体照明[M]. 北京:科学出版社, 2007. SHI G G. Semiconductor Light-emitting Diodes and Solid-state Lighting [M]. Beijing:Science Press, 2007. (in Chinese)

STEIGERWALD D A,BHAT J C,COLLINS D, et al.. Illumination with solid state lighting technology[J]. IEEE J. Sel. Top. Quantum Electron., 2002,8(2):310-320.

徐时清,金尚忠,王宝玲,等. 固体照明光源-白光LED的研究进展[J]. 中国计量学院学报, 2006,17(3):188-191. XU S Q,JIN S Z,WANG B L, et al.. Solid state lighting-recent progress in research of white light emitting diodes[J]. J. China Jiliang Univ., 2006,17(3):188-191. (in Chinese)

肖芬. 紫外激发白光LED荧光粉的制备及发光特性研究[D]. 广州:华南理工大学, 2011. XIAO F. Preparation and Luminescence Properties of Phosphors for UV Excited White Light-emitting Diodes[D]. Guangzhou:South China University of Technology, 2011. (in Chinese)

陶岳彬. GaN基大功率蓝光LED的MOCVD生长和改善效率骤降特性的研究[D]. 北京:北京大学, 2011. TAO Y B. Research on MOCVD Growth and Improvement Efficiency Drop Characteristics of GaN-based High Power Blue LEDs[D]. Beijing:Peking University, 2011. (in Chinese)

KOECHNER W. Solid-state Laser Engineering[M]. New York:Springer, 2006.

RAZUM N J. Laser physics[J]. Facial Plast. Surg., 1989,6(3):137-143.

THOMAS G,ISAACS R. Basic principles of lasers[J]. Anaesth. Intensive Care Med., 2011,12(12):574-577.

HERREROS D N,FANG X. Laser ignition of elastomer-modified cast double-base (EMCDB) propellant using a diode laser[J]. Opt. Laser Technol., 2017,89:21-26.

SELIMIS A,MIRONOV V,FARSARI M. Direct laser writing:principles and materials for Scaffold 3D printing[J]. Microelectron. Eng., 2015,132:83-89.

RODRIGUES G C,DUFLOU J R. Opportunities in laser cutting with direct diode laser configurations[J]. CIRP Ann., 2017,66(1):245-248.

ABSTEN G T. Physics of light and lasers[J]. Obstet. Gynecol. Clin. North Am., 1991,18(3):407-427.

LIU H,SUN C L,WANG W S, et al.. Design of a LCOS laser projector[J]. Optik, 2015,126(15-16):1483-1486.

NARUKAWA Y,NAGAHAMA S I,TAMAKI H, et al.. Development of high-luminance white light source using GaN-based light emitting devices[J]. 應用物理, 2005,74(11):1423-1432.

KOZAKI T,NAGAHAMA S,MUKAI T. Recent progress of high-power GaN-based laser diodes[C]. Proceedings Volume 6485,Novel In-plane Semiconductor Lasers VI,San Jose,California,USA, 2007,6485:648503.

DENAULT K A,CANTORE M,NAKAMURA S, et al.. Efficient and stable laser-driven white lighting[J]. AIP Adv., 2013,3(7):072107-1-7.

WIERERJR J J,TSAO J Y,SIZOV D S. The potential of Ⅲ-nitride laser diodes for solid-state lighting[J]. Phys. Status Solidi C, 2014,11(3-4):674-677.

许礼强. 基于激光远程激发荧光粉(LARP)技术的新型白光光源研究[D]. 深圳:深圳大学, 2015. XU L Q. Study on New White Light Source base on LARP Technology[D]. Shenzhen:Shenzhen University, 2015. (in Chinese)

王子明,黄笑彤,杨波波,等. 低温共烧结制备Lu2.94-xYx Al5O12:0.06Ce荧光玻璃的研究[J]. 光电技术应用, 2017,32(6):39-43. WANG Z M,HUANG X T,YANG B B, et al.. Preparation of Lu2.94-xYx Al5O12:0.06Ce phosphor in glass by low-temperature co-sintering method[J]. Electro-Opt. Technol. Appl., 2017,32(6):39-43. (in Chinese)

KINOSHITA J,IKEDA Y,TAKEDA Y, et al.. Suppressed speckle contrast of blue light emission out of white lamp with phosphors excited by blue laser diodes for high-brightness lighting applications[J]. Opt. Rev., 2012,19(6):427-431.

武传雷. YAG荧光粉的制备和性能研究[D]. 上海:上海师范大学, 2013. WU C L. Preparation and Properties of YAG Phosphors[D]. Shanghai:Shanghai Normal University, 2013. (in Chinese)

浏览量

152

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

暂无数据