磁控溅射制备本征ZnO/Ag/ZnO透明导电薄膜的性质研究

李彤; 周艳文; 王艳雪; 赵卓; 武俊生; 王晓明; 高鹏

doi:10.3788/fgxb20183909.1272

您当前的位置：

首页 >

文章列表页 >

磁控溅射制备本征ZnO/Ag/ZnO透明导电薄膜的性质研究

器件制备及器件物理 | 更新时间：2020-08-12

- 磁控溅射制备本征ZnO/Ag/ZnO透明导电薄膜的性质研究
- Properties of ZnO/Ag/ZnO Transparent Conducting Thin Films Prepared by Magnetron Sputtering
- 发光学报 2018年39卷第9期页码：1272-1279
- 作者机构：
  
  1. 辽宁科技大学化学工程学院,辽宁鞍山,114051
  2. 辽宁科技大学表面工程研究所,辽宁鞍山,114051
  3. 鞍钢集团钢铁研究院海洋装备用金属材料及其应用国家重点实验室,辽宁鞍山,114051
- 作者简介：
- 基金信息：
  
  国家自然科学基金（51672119）();辽宁省教育厅校企成果转化项目（601009817-01）();辽宁省教育厅海洋装备用金属材料及其应用国家重点实验室-辽宁科技大
- DOI：10.3788/fgxb20183909.1272
  中图分类号： TM24;O484.4
- 纸质出版日期：2018-9-5，
  
  网络出版日期：2018-4-16，
  
  收稿日期：2017-12-18，
  
  修回日期：2018-2-9，
扫描看全文
李彤, 周艳文, 王艳雪等. 磁控溅射制备本征ZnO/Ag/ZnO透明导电薄膜的性质研究[J]. 发光学报, 2018,39(9): 1272-1279

LI Tong, ZHOU Yan-wen, WANG Yan-xue etc. Properties of ZnO/Ag/ZnO Transparent Conducting Thin Films Prepared by Magnetron Sputtering[J]. Chinese Journal of Luminescence, 2018,39(9): 1272-1279
李彤, 周艳文, 王艳雪等. 磁控溅射制备本征ZnO/Ag/ZnO透明导电薄膜的性质研究[J]. 发光学报, 2018,39(9): 1272-1279 DOI： 10.3788/fgxb20183909.1272.

LI Tong, ZHOU Yan-wen, WANG Yan-xue etc. Properties of ZnO/Ag/ZnO Transparent Conducting Thin Films Prepared by Magnetron Sputtering[J]. Chinese Journal of Luminescence, 2018,39(9): 1272-1279 DOI： 10.3788/fgxb20183909.1272.

摘要

室温下采用射频磁控溅射氧化锌（ZnO）粉末靶、银（Ag）靶，在玻璃衬底上制备ZnO/Ag/ZnO透明导电薄膜。首先，ZnO厚度为30 nm时，改变Ag厚度制备3层透明导电薄膜，研究Ag层厚度及膜层间配比对光电性能的影响；其次，按ZnO∶Ag厚度比为30∶11比例制备不同厚度的3层透明导电薄膜，研究多层厚度对薄膜光电性能的影响。结果表明：Ag厚度为8 nm及11 nm的ZnO/Ag/ZnO表面相对平整，结晶程度较好，在可见光范围内最高透过率达到90%及86%，并且方块电阻为6 /□及3.20 /□，具有优良的光电性；当按配比制备ZnO/Ag/ZnO 3层膜时，增加ZnO厚度对Ag层的增透作用反而减弱，同时增加Ag层厚度也会降低3层薄膜的整体光学性。

Abstract

At room temperature

ZnO/Ag/ZnO transparent conductive films were prepared on glass substrate by RF magnetron sputtering of zinc oxide(ZnO) powder and silver(Ag). When the thickness of ZnO was 30 nm

the thickness of Ag was changed to prepare three layers of transparent conductive films

and the influence of the thickness of Ag layer and the ratio between the layers on the photoelectric properties were studied. According to the ZnO/Ag ratio of 30:11

different thickness of three transparent conductive films were prepared

and the effect of multilayer thickness on the photovoltaic properties was researched. The results show that the surface of ZnO/Ag/ZnO with thickness of 8 nm and 11 nm are relatively flat

and have good degree of crystallinity with the maximum transmittance of 90% and 86% in the visible range and the sheet resistance of 6 /□ and 3.20 /□. The photoelectricity is excellent. When ZnO/Ag/ZnO three-layer films are prepared according to the ratio of 30:11

increasing the thickness of ZnO layer on the contrary enhances the light transmittance of Ag layer but decreases the overall optical layer thickness of the three-layer films.

关键词

透明导电薄膜射频磁控溅射粉末靶镀膜

Keywords

transparent conductive filmsRF magnetron sputteringpowder targetcoating

references

李荣荣, 赵晋津, 司华燕, 等. 柔性薄膜太阳能电池的研究进展[J]. 硅酸盐学报, 2014, 42(7):878-883. LI Y Y, ZHAO J J, SI H Y, et al.. Research progress of flexible thin film solar cells[J]. J. Silicate, 2014, 42(7):878-883. (in Chinese)

申德振, 梅增霞, 梁会力, 等. 氧化锌基材料、异质结构及光电器件[J]. 发光学报, 2014, 35(1):1-60. SHEN D Z, MEI Z X, LIANG H L, et al.. Zinc oxide based materials, heterostructures and optoelectronic devices[J]. Chin. J. Lumin., 2014, 35(1):1-60. (in Chinese)

廖雅琴, 李愿杰, 黄添懋, 等. 透明导电薄膜现状与发展趋势[J]. 东方电气评论, 2014, 128(109):13-18. LIAO Y Q, LI Y J, HUANG T M, et al.. Status and development trend of transparent conductive film[J]. Dongfang Electric Rev., 2014, 128(109):13-18. (in Chinese)

刘晓菲, 王小平, 王丽军, 等. 透明导电薄膜的研究进展[J]. 激光与光电子学进展, 2012, 49(10):26-35. LIU X F, WANG X P, WANG L J, et al.. Research progress of transparent conductive thin films[J]. Laser Optoelectron. Prog., 2012, 49(10):26-35. (in Chinese)

李源浩, 武聪伶, 杨君礼, 等. 基于MoO3/Ag/MoO3透明阳极的顶发射OLED的模拟计算与制备[J]. 发光学报, 2015, 36(4):459-465. LI Y H, WU C L, YANG J L, et al.. Simulation and preparation of top emitting OLED based on MoO3/Ag/MoO3 transparent anode[J]. Chin. J. Lumin., 2015, 36(4):459-465. (in Chinese)

于仕辉, 丁玲红, 薛闯, 等. 氧氩比对SnO2/Ag/SnO2透明导电膜光电性能的影响[J]. 光子学报, 2012, 41(9):1086-1089. YU S H, DING L H, XUE C, et al.. Influence of O2/Ar ration on the properties of transparent conductive SnO2/Ag/SnO2trilayer film[J]. Acta Photon. Sinica, 2012, 41(9):1086-1089. (in Chinese)

TANG K, GU S L, YE J D, et al.. Mutually beneficial doping of tellurium and nitrogen in ZnO films grown by metal-organic chemical vapor deposition[J]. J. Vac. Sci. Technol. A, 2012, 30(5):051508-1-9.

刘思宁, 周艳文, 吴川, 等. 粉末靶制备的AZO/Ag/AZO透明导电薄膜的光电性能[J]. 发光学报, 2015, 36(12):1427-1433. LIU S N, ZHOU Y W, WU C, et al.. Optical and electrical properties of AZO/Ag/AZO transparent conductive films prepared by RF magnetron sputtering using powder targets[J]. Chin. J. Lumin., 2015, 36(12):1427-1433. (in Chinese)

吴伟梁, 林文杰, 赵影文, 等. 金属氧化物多层膜背接触晶体硅太阳电池[J]. 太阳能, 2017(4):35-38. WU W L, LIN W J, ZHAO Y W, et al.. Metal oxide multilayer film back contact crystalline silicon solar cells[J]. Solar Energy, 2017(4):35-38. (in Chinese)

孙瑶, 汪洪. 介质/金属/介质透明导电多层膜的椭圆偏振光谱研究[J]. 激光与光电子学进展, 2016, 53(10):259-266. SUN Y, WANG H. Ellipsometric study of D/M/D transparent conductive multilayers[J]. Laser Optoelectron. Prog., 2016, 53(10):259-266. (in Chinese)

郭亮, 赵东旭, 张振中, 等. ZnO/Ag/ZnO多层结构薄膜的光电性质[J]. 发光学报, 2011, 32(9):920-923. GUO L, ZHAO D X, ZHANG Z Z, et al.. Photoelectric properties of ZnO/Ag/ZnO multilayer structure thin films[J]. Chin. J. Lumin., 2011, 32(9):920-923. (in Chinese)

刘汉法, 张化福, 王振环. 薄膜厚度对TGZO透明导电薄膜光电性能的影响[J]. 真空科学与技术学报, 2011, 31(2):183-186. LIU H F, ZHANG H F, WANG Z H. Effect of film thickness on photoelectric properties of TGZO transparent conductive thin films[J]. J. Vac. Sci. Technol., 2011, 31(2):183-186. (in Chinese)

战可涛, 曾凡强. 铝镧共掺ZnO透明导电薄膜的微观结构和光电性能研究[J]. 光学学报, 2011, 31(s1):s100110. ZHAN K T, ZENG F Q. Microstructure and optical and electrical properties of Al-lanthanum-doped ZnO transparent conducting thin films[J]. Acta Opt. Sinica, 2011, 31(s1):s100110. (in Chinese)

VAN EEK S, YAN X, LI W M, et al.. Investigation of material properties and thermal stabilities of magnetron-sputter-deposited ZnO:Al/Ag/ZnO:Al transparent conductive coatings for thin-film solar cell applications[J]. Jpn. J. Appl. Phys., 2017, 56:08MA12-1-6.

KIM J H, LEE J H, KIM S W, et al.. Highly flexible ZnO/Ag/ZnO conducting electrode for organic photonic devices[J]. Ceram. Int., 2015, 41:7146-7150.

汤洋, 郭逦达, 张增光, 等. 硝酸铵诱导电沉积氧化锌纳米柱的铝掺杂及光学性质操控[J]. 光学精密工程, 2015, 23(5):1288-1296. TANG Y, GUO L D, ZHANG Z G, et al.. Aluminum doping and optical property control of electrodeposited zinc oxide nanorods induced by ammonium nitrate[J]. Opt. Precision Eng., 2015, 23(5):1288-1296. (in Chinese)

彭廉钦, 田晶, 王域, 等. 磁控溅射制备CdS/ZnO复合薄膜及其光电性能研究[J]. 西南民族大学学报(自然科学版), 2015, 41(1):77-82. PENG L Q, TIAN J, WANG Y, et al.. Preparation of CdS/ZnO composite films by magnetron sputtering and their photoelectric properties[J]. J. Southwest Univ. Nation.(Na.Sci. Edi.), 2015, 41(1):77-82. (in Chinese)

ANDO E, MIYAZAKI M. Moisture resistance of the low-emissivity coatings with a layer structure of Al-doped ZnO/Ag/Aldoped ZnO[J]. Thin Solid Films, 2001, 392(2):289-294.

MEREU B, CAGLAR O, CASHMORE J S, et al.. Window p-layer in amorphous pin solar cells using ZnO as trans-parent conductive oxide[J]. Solar Energy Mater. Solar Cells, 2016, 152:147-154.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

粉末靶制备的AZO/Ag/AZO透明导电薄膜的光电性能

高真空磁控溅射温度对Ga₂O₃微观结构及光学性能的影响

氮掺铟锡锌薄膜晶体管的制备及其光电特性

射频磁控溅射法制备SnS₂薄膜结构和光学特性的研究

射频磁控溅射法制备SnS薄膜及其结构和光学特性