溶胶凝胶法制备透明IZO薄膜晶体管

信恩龙; 李喜峰; 张建华

doi:10.3788/fgxb20133402.0208

您当前的位置：

首页 >

文章列表页 >

溶胶凝胶法制备透明IZO薄膜晶体管

器件制备及器件物理 | 更新时间：2020-08-12

- 溶胶凝胶法制备透明IZO薄膜晶体管
- Fabrication of Transparent Indium Zinc Oxide Thin Film Transistors by Sol-gel Technology
- 发光学报 2013年34卷第2期页码：208-212
- 作者机构：
  
  上海大学新型显示技术及应用集成教育部重点实验室, 上海 200072
- 作者简介：
- 基金信息：
  
  国家自然科学基金(61006005)();上海市科学技术委员会项目(10dz1100102)资助项目()
- DOI：10.3788/fgxb20133402.0208
  中图分类号： TN321+.5
- 纸质出版日期：2013-2-10，
  
  收稿日期：2012-12-2，
  
  修回日期：2012-12-12，
扫描看全文
信恩龙, 李喜峰, 张建华. 溶胶凝胶法制备透明IZO薄膜晶体管[J]. 发光学报, 2013,34(2): 208-212

XIN En-long, LI Xi-feng, ZHANG Jian-hua. Fabrication of Transparent Indium Zinc Oxide Thin Film Transistors by Sol-gel Technology[J]. Chinese Journal of Luminescence, 2013,34(2): 208-212
信恩龙, 李喜峰, 张建华. 溶胶凝胶法制备透明IZO薄膜晶体管[J]. 发光学报, 2013,34(2): 208-212 DOI： 10.3788/fgxb20133402.0208.

XIN En-long, LI Xi-feng, ZHANG Jian-hua. Fabrication of Transparent Indium Zinc Oxide Thin Film Transistors by Sol-gel Technology[J]. Chinese Journal of Luminescence, 2013,34(2): 208-212 DOI： 10.3788/fgxb20133402.0208.

摘要

采用溶胶凝胶法制备了非晶铟锌氧化物(a-IZO)薄膜

并作为薄膜晶体管(TFT)的有源层制备了a-IZO TFT。研究了IZO薄膜中铟锌比对薄膜性质及a-IZO TFT器件性能的影响。结果表明:溶胶凝胶法制备的IZO薄膜经低温(300 ℃)退火后为非晶结构

薄膜表面均匀平整、致密

颗粒大小为20 nm左右

并具有高透过率(＞85 %)。IZO薄膜中的铟锌比对薄膜的电学性能和TFT器件特性影响显著

增加In含量有利于提高薄膜和器件的迁移率。当铟锌比为3∶2时

所获得的薄膜适合于作为薄膜晶体管的有源层

制备的IZO-TFT经过相对低温(300 ℃)退火处理具有较好的器件性能

阈值电压为1.3 V

载流子饱和迁移率为0.24 cm

-1

开关比(I

∶I

off

)为10

。

Abstract

The amorphous InZnO (a-IZO) thin films were prepared by sol-gel technology

and thin film transistors (TFTs) were further fabricated by employing the IZO films as the active channel layer after low temperature (300 ℃) annealing treatment. The influence of indium concentration on the electrical properties of IZO thin films and the IZO-TFTs was investigated in this paper. The results revealed that the IZO film was amorphous

surface was uniform and smooth

grain about 20 nm

and the visible average optical transmittance was more than 85%. IZO-TFT with a threshold voltage of 1.3 V

a mobility of 0.24 cm

-1

and a I

∶I

off

current ratio of 10

was obtained when

(In)∶

(Zn)=3∶2.

关键词

溶胶凝胶法铟锌氧化物薄膜薄膜晶体管低温

Keywords

sol-gel technologyindium zinc oxidethin film transistorlow temperature

references

Bae C D, Kim D J, Moon S, et al. Aging dynamics of solution-processed amorphous oxide semiconductor field effect transistors [J]. Appl. Mater. Inter., 2010, 2(3):626-632.[2] Kim Y H, Han M K, Han J I, et al. Effect of metallic composition on electrical properties of solution-processed indium-gallium-zinc-oxide thin-film transistors [J]. IEEE Trans. Electron Device, 2010, 57(5):1009-1014.[3] Nomura K, Ohta H, Takagi A, et al. Room-temperature fabrication of transparent flexible thin-film transistors using amorphous oxide semiconductors [J]. Nature, 2004, 432:488-492.[4] Chen T C, Chang T C, Hsieh T Y, et al. Investigating the degradation behavior caused by charge trapping effect under DC and AC gate-bias stress for InGaZnO thin film transistor [J]. Appl. Phys. Lett., 2011, 99(2):022104-1-3.[5] Kumar B, Gong H, Akkipeddi R. High mobility undoped amorphous indium zinc oxide transparent thin films [J]. J. Appl. Phys., 2005, 98(7):073703-1-6.[6] Xin E L, Li X F, Chen L L, et al. Fabrication of amorphous indium gallium zinc oxide thin film transistor at low temperature by RF magnetron sputtering [J]. Chin. J. Lumin.(发光学报), 2012, 33(10):1149-1152 (in Chinese).[7] Park S K, Kim Y H, Han J I. All solution-processed high-resolution bottom-contact transparent metal-oxide thin film transistors [J]. J. Phys. D: Appl. Phys., 2009, 42:125102-1-6.[8] Yang Y H, Yang S S, Kao C Y, et al. Chemical and electrical properties of low-temperature solution-processed In-Ga-Zn-O thin-film transistors [J]. IEEE Electron Device Lett., 2010, 31(4):329-331.[9] Kim C E, Cho E N, Moon P, et al. Density-of-states modeling of solution-processed InGaZnO thin-film transistors [J]. IEEE Electron Device Lett., 2010, 31(10):1131-1133.[10] Kim G H, Ahn B D, Shin H S, et al. Effect of indium composition ratio on solution-processed nanocrystalline InGaZnO thin film transistors [J]. Appl. Phys. Lett., 2009, 94(23):233501-1-3.[11] Kim D, Koo C Y, Song K K, et al. Compositional influence on sol-gel-derived amorphous oxide semiconductor thin film transistors [J]. Appl. Phys. Lett., 2009, 95(10):103501-1-3.[12] Lim J H, Shim J H, Choi J H, et al. Solution-processed InGaZnO-based thin film transistors for printed electronics applications [J]. Appl. Phys. Lett., 2009, 95(1):012108-1-3.[13] Wang X Y, Dong G F, Qiao J, et al. Preparation and field-effect property of solution-processed multilayer zinc oxide [J]. Acta Phys.-Chim. Sinica (物理化学学报), 2010, 26(1):249-252 (in Chinese).[14] Wang X Y, Dong G F, Qiao J, et al. Solution-processed zinc oxide thin films and top-gate thin film transistors [J]. Chin. J. Inorg. Chem.(无机化学学报), 2009, 25(12):2071-2076 (in Chinese).[15] Kim M G, Kanatzidis M G, Facchetti A, et al. Low-temperature fabrication of high-performance metal oxide thin-film electronics via combustion processing [J]. Nat. Mater., 2011, 10(5):382-388.[16] Jeong Y M, Bae C D, Kim D J, et al. Bias-stress-stable solution-processed oxide thin film transistors [J]. Appl. Mater. Inter., 2010, 2(3):611-615.[17] Kamiya T, Nomura K, Hosono H. Present status of amorphous In-Ga-Zn-O thin-film transistors [J]. Sci. Technol. Adv. Mater., 2010, 11(4):044305-1-5.[18] Ide K, Kikuchi Y, Nomura K, et al. Effects of excess oxygen on operation characteristics of amorphous In-Ga-Zn-O thin-film transistors [J]. Appl. Phys. Lett., 2011, 99(9):093507-1-3.[19] Jeong S, Ha Y G, Moon J, et al. Role of gallium doping in dramatically lowering amorphous oxide-processing temperatures for solution-derived indium zinc oxide thin-film transistors [J]. Adv. Mater., 2010, 22(12):1346-1350.[20] Pasquarelli R M, Ginley D S, Hayre R O. Solution processing of transparent conductors: From flask to film [J]. Chem. Soc. Rev., 2011, 40(11):5406-5441.[21] Song K, Kim D, Li X S, et al. Solution processed invisible all-oxide thin film transistors [J]. J. Mater. Chem., 2009, 19(46):8881-8886.[22] Jeong W H, Bae J H, Kim H J. High-performance oxide thin-film transistors using a volatile nitrate precursor for low-temperature solution process [J]. IEEE Electron Device Lett., 2012, 33(1):68-70.[23] Chen C K, Hsieh H H, Shyue J J, et al. The influence of channel compositions on the electrical properties of solution-processed indium-zinc oxide thin-film transistors [J]. J. Display Technol., 2009, 5(12): 509-514.[24] Park K B, Seon J B, Kim G H, et al. High electrical performance of wet-processed indium zinc oxide thin-film transistors [J]. IEEE Electron Device Lett., 2010, 31(4):311-313.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

低温808 nm高效率半导体激光器

InGaAs/GaAs/InGaP量子阱激光器的温度电压特性

发光薄膜沉积技术中薄膜晶体管的优化设计

硅掺杂氧化锡柔性薄膜晶体管的制备与特性

利用变温瞬态电致发光研究OLED载流子的输运机理