浏览全部资源
扫码关注微信
1. 长春工业大学 化学工程学院,吉林 长春,130012
2. 长春理工大学 光电工程学院,吉林 长春,130022
纸质出版日期:2018-2-5,
网络出版日期:2017-11-23,
收稿日期:2017-8-28,
修回日期:2017-10-23,
扫 描 看 全 文
李占国, 张沛沛, 张梁等. 溶液法制备PVP为界面修饰层的红荧烯结晶性薄膜[J]. 发光学报, 2018,39(2): 148-155
LI Zhan-guo, ZHANG Pei-pei, ZHANG Liang etc. Rubrene Crystal Films Using PVP as Interface Modification Layer Fabricated by Solution Methods[J]. Chinese Journal of Luminescence, 2018,39(2): 148-155
李占国, 张沛沛, 张梁等. 溶液法制备PVP为界面修饰层的红荧烯结晶性薄膜[J]. 发光学报, 2018,39(2): 148-155 DOI: 10.3788/fgxb20183902.0148.
LI Zhan-guo, ZHANG Pei-pei, ZHANG Liang etc. Rubrene Crystal Films Using PVP as Interface Modification Layer Fabricated by Solution Methods[J]. Chinese Journal of Luminescence, 2018,39(2): 148-155 DOI: 10.3788/fgxb20183902.0148.
为了获得低成本、高结晶度的红荧烯薄膜,采用溶液加工的方法和聚合物界面修饰层研究了红荧烯薄膜的性质。首先,通过旋涂方法在Si/SiO
2
衬底上先沉积一层聚乙烯吡咯烷酮(PVP)作为界面修饰层,利用偏光显微镜(POM)、原子力显微镜(AFM)研究了PVP层表面形貌及粗糙度。接着在PVP上滴涂红荧烯溶液后固化烘干,制备红荧烯晶体薄膜,研究了不同PVP浓度和不同成膜温度下界面修饰层对红荧烯表面形貌的影响。然后,利用X射线衍射(XRD)表征对比研究了薄膜的微观结构。最后,分析了红荧烯晶体薄膜的生长机制。实验结果表明:80~140℃及低浓度的PVP条件下能得到结晶度高、连续的红荧烯球晶,并且温度升高时,球晶尺寸变大。PVP作为界面修饰层有利于改善红荧烯的成膜性,制备高结晶度的晶体薄膜。
In order to obtain the low cost and high crystalline thin films
the properties of rubrene films were investigated with Polyvinyl Pyrrolidone (PVP) as interface modification layer on the Si/SiO
2
substrate by solution process. First
PVP films were spin-coated on Si/SiO
2
substrate. The surface morphology and roughness (RMS) of PVP layer were analyzed by polarizing optical microscope (POM) and atomic force microscopy (AFM). Then
rubrene films were drop-coated on the PVP layer and dried out. The effects of PVP layer with the different PVP concentration and film-forming temperature on rubrene morphology were studied. The crystal structures of PVP films and rubrene films were carried out by X-ray diffraction. Finally
growth mechanism mode of rubrene films on the PVP interface modification layer was proposed. The results indicate that the temperature of 80-140℃ and lower concentration of PVP are apt to prepare spherulites with high crystallinity
and the crystals size becomes larger when the temperature increases. PVP used as interface modification layer is beneficial to improve film-forming property of rubrene and prepare crystalline films with high crystallinity.
溶液法聚乙烯吡咯烷酮界面修饰红荧烯晶体晶体形貌
solution processPolyvinyl Pyrrolidone(PVP)interface modificationrubrene crystalscrystal morphology
NAJAFOV H, LYU B, BIAGGIO I, et al.. Two mechanisms of exciton dissociation in rubrene single crystals[J]. Appl. Phys. Lett., 2010, 96(18):183302.
陈星明, 胡胜坤, 金玉, 等. 不同发光染料的顶发射有机电致发光器件的研制[J]. 发光学报, 2016, 37(4):446-451. CHEN X M, HU S K, JIN Y, et al.. Top-emitting organic light-emitting devices with different luminescent dyes[J]. Chin. J. Lumin., 2016, 37(4):446-451. (in Chinese)
PU H, LI H, YANG Z, et al.. Effect of content ratio on solution-processed high-k titanium-aluminum oxide dielectric films[J]. ECS Solid State Lett., 2013, 2(10):N35-N38.
ZHU L, GAO Y, LI X, et al.. Development of high-k hafnium-aluminum oxide dielectric films using sol-gel process[J]. J. Mater. Res., 2014, 29(15):1620-1625.
HAMILTON R, SMITH J, OGIER S, et al.. High-performance polymer-small molecule blend organic transistors[J]. Adv. Mater., 2009, 21(10-11):1166-1171.
SHIN N, KANG J, RICHTER L J, et al.. Vertically segregated structure and properties of small molecule-polymer blend semiconductors for organic thin-film ratnsistors[J]. Adv. Funct. Mater., 2013, 23(3):366-376.
林广庆, 李鹏, 熊贤风, 等. 不同表面修饰制备高性能柔性薄膜晶体管[J]. 发光学报, 2013, 34(10):1392-1399. LIN G Q, LI P, XIONG X F, et al.. Preparation of high-performance flexible organic thin-film transistor through different dielectric surface modification[J]. Chin. J. Lumin., 2013, 34(10):1392-1399. (in Chinese)
龙宇升, 康正, 廖列文, 等. 聚乙烯吡略烷酮的性质及测定[J]. 广州化工, 1999, 27(2):33-35. LONG Y S, KANG Z, LIAO L W, et al.. Properties and determination of polyvinyl pyrrolidone[J]. Guangzhou Chem. Ind., 1999, 27(2):33-35. (in Chinese)
YU X, YU X, ZHANG J, et al.. Efficiency boosting of inverted polymer solar cells with a polyvinylpyrrolidone-modified Al-doped ZnO electron transport layer[J]. Solar Energy Mater. Solar Cells, 2014, 128(9):307-312.
SU Y, LIU J, ZHENG L, et al.. Polymer assisted solution-processing of rubrene spherulites via solvent vapor annealing[J]. RSC Adv., 2012, 2(13):5779-5788.
JO P S, DUONG D T, PARK J, et al.. Control of rubrene polymorphs via polymer binders:applications in organic field-effect transistors[J]. Chem. Mater., 2015, 27(11):3979-3987.
张玉婷, 王卓, 孙洋, 等. 红荧烯薄膜生长及稳定性的研究[J]. 发光学报, 2017, 38(8):1047-1055. ZHANG Y T, WANG Z, SUN Y, et al.. Growth and stability properties of rubrene thin films[J]. Chin. J. Lumin., 2017, 38(8):1047-1055. (in Chinese)
WANG L, LI Y, ZOU F, et al.. Insight into crystallization process of rubrene by binary solvent mixtures[J]. RSC Adv., 2016, 6(5):3532-3538.
DIMITRAKOPOULOS C D, BROWN A R, POMP A. Molecular beam deposited thin films of pentacene for organic field effect transistor applications[J]. J. Appl. Phys., 1996, 80(4):2501-2508.
PARK S W, HWANG J M, CHOI J M, et al.. Rubrene thin-film transistors with crystalline and amorphous channels[J]. Appl. Phys. Lett., 2007, 90(15):153512.
LEE W H, LIM J A, KIM D H, et al.. Room-temperature self-organizing characteristics of soluble acene field-effect transistors[J]. Adv. Funct. Mater., 2008, 18(4):560-565.
征茂平, 顾明元, 金燕苹, 等. Ag-PVP复合薄膜的制备及其光谱特性[J]. 光学技术, 2000, 26(6):494-498. ZHENG M P, GU M Y, JIN Y P, et al.. Preparation absorption spectra of Ag-PVP nanocomposite film[J]. Opt. Tech., 2000, 26(6):494-498. (in Chinese)
RIBIC P R, KALIHARI V, FRISBIE C D, et al.. Growth of ultrathin pentacene films on polymeric substrates[J]. Phys. Rev. B, 2009, 80(11):115307.
TIWARI S P, KNAUER K A, DINDAR A, et al.. Performance comparison of pentacene organic field-effect transistors with SiO2 modified with octyltrichlorosilane or octadecyltrichlorosilane[J]. Org. Electron., 2012, 13(1):18-22.
NORTON D R, KELLER A. The spherulitic and lamellar morphology of melt-crystallized isotactic polypropylene[J]. Polymer, 1985, 26(5):704-716.
FIELITZ T R, HOLMES R J. Crystal morphology and growth in annealed rubrene thin films[J]. Cryst. Growth Design, 2016, 16(8):4720-4726.
LUO L, LIU G, HUANG L, et al.. Solution-based patterned growth of rubrene nanocrystals for organic field effect transistors[J]. Appl. Phys. Lett., 2009, 95(26):263312.
GRNSY L, PUSZTAI T, TEGZE G, et al.. Growth and form of spherulites[J]. Phys. Rev.E, 2005, 72(1):011605.
PARK S W, CHOI J M, LEE K H, et al.. Amorphous-to-crystalline phase transformation of thin film rubrene[J]. J. Phys. Chem. B, 2010, 114(17):5661-5665.
0
浏览量
42
下载量
0
CSCD
关联资源
相关文章
相关作者
相关机构