SiO₂包覆的β-NaYF₄：Eu³⁺及透明发光薄膜的制备和性能研究

SiO 2 包覆的-NaYF 4 ：Eu 3+ 及透明发光薄膜的制备和性能研究 Preparation and Properties of SiO 2 Coated -NaYF 4 ：Eu 3+ Transparent Luminescent Thin Films 蒋晨飞 JIANG Chen-fei first-author 黄文娟 HUANG Wen-juan 丁明烨 DING Ming-ye 黄亨明 HUANG Heng-ming 倪亚茹 NI Ya-ru 陆春华 LU Chun-hua 许仲梓 XU Zhong-zi 南京工业大学 材料科学与工程学院, 江苏 南京 210009 南京工业大学 材料科学与工程学院, 江苏 南京 210009 College of Materials Science and Engineering, Nanjing University of Technology, Nanjing 210009, China College of Materials Science and Engineering, Nanjing University of Technology, Nanjing 210009, China 通过溶胶-凝胶方法对-NaYF 4 :Eu 3+ 进行了表面SiO 2 包裹处理,并将其分散于溶胶中提拉成膜,制备成发光薄膜。采用XRD、SEM、TEM、FTIR、UVPC、PL等测试手段进行了分析表征。结果表明:NaYF 4 表面被成功包裹上了一层SiO 2 ,形成了核壳结构,并除去了表面油酸等有机物。表面包裹对NaYF 4 的晶型结构没有产生影响,但荧光性能略有下降,形貌趋向于圆形,这是由于表面SiO 2 颗粒在形成网络结构的张力和溶剂溶解所致。采用提拉浸渍镀膜后,发光粒子比较好地分散在薄膜上,并且具有比较理想的透过率,呈现出一定的减反射效果。由于SiO 2 包裹和热处理,O 2- 空位缺陷增强了Eu 3+ 在420~500nm波段的发光,这对整个发光性能是有利的。而因为能量转移,产生无辐射跃迁,613nm处发光产生猝灭。通过实验,优化确定了制备发光薄膜的最佳工艺。 -NaYF 4 : Eu 3+ @SiO 2 nanoparticles were prepared by sol-gel method and were dispersed in the sol to obtain luminescent thin films through dip-coating process. XRD,SEM,TEM,FTIR,UVPC and PL were used to characterized the nanoparticles and transparent films. The results indicated that the oleic-acid was removed from the nanoparticles and SiO 2 was coated on the particles successfully. The SiO 2 shell has no influence on the crystalline structure and its fluorescence perfor-mance declines slightly. The morphology of -NaYF 4 : Eu 3+ transforms to nanospheres due to the solvent solution and tension of network structure of SiO 2 . The nanoparticles were dispersed in the thin films uniformly, and the films also have good transmittance and minus reflection effect. After coating and thermal treatment, the luminescence intensity from 420 to 500 nm was enhanced owing to the oxygen vacancy. But the luminescence at 613 nm quenches because of the energy transfer and nonradiative transition. The optimal technological parameters of the films were obtained by testing. 溶胶-凝胶法 &beta -NaYF 4 ：Eu 3+ SiO 2 包裹 发光薄膜 sol-gel method &beta -NaYF 4 ：Eu 3+ SiO 2 coating luminescent thin films Weissleder R, Ntziachristos V. Shedding light onto live molecular targets [J]. Nat. Med., 2003, 9(1):123-128.[2] Intes X, Ripoll J, Chen Y, et al. In vivo continuous-wave optical breast imaging enhanced with Indocyanine [J]. Green Med. Phys., 2003, 30(6):1039-1047.[3] Imbert D, Cabtuel M, Bunzli J C, et al. Extending lifetimes of lanthanide-based near-infrared emitters (Nd, Yb) in the millisecond range through Cr(III) sensitization in discrete bimetallic edifices [J]. J. Am. Chem. Soc., 2003, 125(51):15698-15699.[4] Wolcott A, Gerion D, Visconte M, et al. Silica-coated CdTe quantum dots functionalized with thiols for bioconjugation to IgG proteins [J]. J. Phys. Chem. B, 2006, 110(11):5779-5789.[5] Feng L Y, Kong X G. Preparation and characterization of fluorescence CdSe-liposome compound [J]. Chin. J. Lumin.(发光学报), 2007, 28(3):417-420 (in Chinese).[6] Feng B, Teng F, Tang A W, et al. Application of aminophenol-stabilized CdSe nanocrystals as a fluorescent label for lysozyme [J]. Chin. J. Lumin.(发光学报), 2007, 28(3):421-424 (in Chinese).[7] Qian H F, Dong C Q, Peng J L, et al. High-quality and water-soluble near-infrared photoluminescent CdHgTe/CdS quantum dots prepared by adjusting size and composition [J]. J. Phys. Chem. C, 2007, 111(45):16852-16857.[8] Bailey R E, Nie S M. Alloyed semiconductor quantum dots: Tuning the optical properties without changing the particle size [J]. J. Am. Chem. Soc., 2003, 125(23):7100-7106.[9] Derfus A M, Chan W C W. Probing the cytotoxicity of semiconductor quantum dots [J]. Nano Lett., 2004, 4(l):11-18.[10] Buse G, Preda E, Stef M, et al. Influence of Yb3+ ions on the optical properties of double-doped Er,Yb:CaF2 crystals [J]. Physica Scripta, 2011, 83(2):025604.[11] Sharma Y K, Surana S S L, Singh R K. Spectral studies of erbium doped soda lime silicate glasse in visible and near infrared regions [J]. Opt. Mater., 2007, 29(6):598-604.[12] Mizoguchi H, Woodward P W, Park C, et al. Strong near-infrared luminescence in BaSnO3 [J]. J. Am. Chem. Soc., 2004, 126(31):9796-9800.[13] Sano H, Herber R H. On the mssbauer parameters of bariumstannate [J]. Inorg. Nucl. Chem., 1968, 30(2):409-413.[14] Wagner G, Binder H. Untersuchung der binaren systeme BaO-SnO2 und BaO-PbO2.I. phasenanalysen [J]. Z. Anorg. Allg. Chem., 1958, 297:328-346.[15] Udawatte C P, Yoshimura M. Preparation of well-crystallized BaSnO3 powders under hydrothermal conditions [J]. Mater. Lett., 2001, 47(1/2):7-10.[16] Lu W S, Schmidt H. Hydrothermal synthesis of nanocrystalline BaSnO3 using a SnO2·xH2O sol [J]. J. Eur. Ceram. Soc., 2005, 25(6):919-925.[17] Lu W S, Schmidt H. Synthesis of tin oxide hydrate (SnO2·xH2O) gel and its effects on the hydrothermal preparation of BaSnO3 powders [J]. Adv. Powder Technol., 2008, 19(1):1-12.[18] Lu W S, Schmidt H. Lyothermal synthesis of nanocrystalline BaSnO3 powders [J]. Ceram. Inter., 2008, 34(3):645-649.[19] de Boer W D A M, Timmerman D, Dohnalova K, et al. Red spectral shift and enhanced quantum efficiency in phonon-free photoluminescence from silicon nanocrystals [J]. Nat. Nanotechnol., 2010, 5(12):878-884. 10.3788/fgxb20133401.0012 O482.31 国家自然科学基金(20901040/B0111);江苏省高校自然科学研究重大项目(10KJA430016);江苏省普通高校研究生科研创新计划(CXLX11-0355,CXZZ11-0330);江苏高校优势学科建设工程(PADP);江苏省高等学校大学生实践创新训练计划立项项目(2012JSSPITP0872)资助项目 2012-01-25 2012-06-24 2013-01-10 2020-08-11 1 34