Electrode Preparation of Solar Blind UV Detector Based on Polycrystalline Diamond Films

CHEN Zi-yi; ZHANG Wei-liang; RONG Xi-ming; HAN Shun; ZENG Yu-xiang; CAO Pei-jiang; FANG Ming; LIU Wen-jun; ZHU De-liang; LYU You-ming

doi:10.37188/CJL.20220279

您当前的位置：

首页 >

文章列表页 >

Electrode Preparation of Solar Blind UV Detector Based on Polycrystalline Diamond Films

Device Fabrication and Physics | 更新时间：2023-02-13

- Electrode Preparation of Solar Blind UV Detector Based on Polycrystalline Diamond Films
  增强出版
- Chinese Journal of Luminescence Vol. 43, Issue 12, Pages: 1974-1982(2022)
- 作者机构：
  
  深圳大学材料学院，深圳市特种功能材料重点实验室，广东省功能材料界面工程研究中心，广东深圳　518055
- 作者简介：
- 基金信息：
  
  the National Natural Science Foundation of China(51872187;11774241;12074263;21805194);the Natural Science Foundation of Guangdong Province(2021A1515012013);the Fundamental Research Project of Shenzhen(JCYJ20180508163404043;JCYJ2018030507182248925)
- DOI：10.37188/CJL.20220279
  CLC： O482.31;TN36
- Published：05 December 2022，
  
  Received：22 July 2022，
  
  Revised：04 August 2022，
扫描看全文
陈子依,张伟亮,荣曦明等.多晶金刚石薄膜日盲紫外探测器件的电极制备[J].发光学报,2022,43(12):1974-1982.

CHEN Zi-yi,ZHANG Wei-liang,RONG Xi-ming,et al.Electrode Preparation of Solar Blind UV Detector Based on Polycrystalline Diamond Films[J].Chinese Journal of Luminescence,2022,43(12):1974-1982.
陈子依,张伟亮,荣曦明等.多晶金刚石薄膜日盲紫外探测器件的电极制备[J].发光学报,2022,43(12):1974-1982. DOI： 10.37188/CJL.20220279.

CHEN Zi-yi,ZHANG Wei-liang,RONG Xi-ming,et al.Electrode Preparation of Solar Blind UV Detector Based on Polycrystalline Diamond Films[J].Chinese Journal of Luminescence,2022,43(12):1974-1982. DOI： 10.37188/CJL.20220279.

摘要

通过在直流等离子体喷射化学气相沉积（DC⁃PJCVD）法生长的多晶金刚石薄膜上制备Au叉指电极，构建了金属⁃半导体⁃金属（MSM）结构的日盲紫外探测器件。研究了不同光刻工艺对制备的金刚石探测器件性能的影响。结果表明，lift⁃off光刻工艺所制备的器件性能明显优于湿法光刻工艺器件，其

light

提高了4.4倍，光暗电流比提高了6.8倍，在25 V电压下响应度提高了9倍，达到了0.15 A/W。在此基础上通过lift⁃off光刻工艺制备了Au、Ti、Ti/Au和Ag四种不同金属的叉指电极，对比了不同金属电极制备的金刚石紫外探测器件的性能差异。其中Ag电极由于存在势垒隧穿效应引起的增益，在四种电极中性能表现最佳，在25 V偏压下其

light

高达0.21 μA，响应度提升到0.78 A/W，性能与已有报道的器件性能相当。与普通Au电极制备的器件相比，其光电流提高了5.2倍，光暗电流比提升了7倍，响应度提高了5.2倍。

Abstract

A metal-semiconductor-metal（MSM） structure solar blind UV detector was constructed by preparing interdigital Au electrode on polycrystalline diamond films grown by DC plasma jet chemical vapor deposition （DC-PJCVD）. The effects of different photolithography processes on the performance of the diamond detector were studied， and the results show that the performance of the device prepared by lift-off photolithography is significantly better than that prepared by wet procedure photolithography. The photocurrent of the device is increased by 4.4 times， the light-dark current ratio is increased by 6.8 times， and the responsivity is increased by 9 times to 0.15 A/W at 25 V. On this basis， the interdigitated electrodes of Au， Ti， Ti/Au and Ag were prepared by lift-off photolithography. The performance differences of diamond UV detectors prepared by different metal electrodes were compared. The Ag electrode has the best performance among the four electrodes due to the gain caused by the barrier tunneling effect. At 25 V bias， the light current is 0.21 μA， and responsivity increases to 0.78 A/W. Compared with common Au electrode， the photocurrent， light-dark current ratio and responsivity are increased by 5.2 times， 7 times and 5.2 times respectively.

关键词

金刚石薄膜lift-off光刻工艺Ag电极日盲紫外探测器

Keywords

diamond filmslift-off photolithographyAg electrodesolar blind ultraviolet detector

references

BADILA M， BREZEANU G， MILLAN J， et al. Lift-off technology for SiC UV detectors ［J］. Diamond Relat. Mater.， 2000， 9（3-6）： 994-997.

FLANNERY L B， HARRISON I， LACKLISON D E， et al. Fabrication and characterization of p-type GaN metal-semiconductor-metal ultraviolet photoconductors grown by MBE ［J］. Mater. Sci. Eng. B， 1997， 50（1-3）： 307-310.

MOON T H， JEONG M C， LEE W， et al. The fabrication and characterization of ZnO UV detector ［J］. Appl. Surf. Sci.， 2005， 240（1-4）： 280-285.

ZHONG M Z， WEI Z M， MENG X Q， et al. High-performance single crystalline UV photodetectors of β-Ga2O3 ［J］. J. Alloys Compd.， 2015， 619： 572-575.

DE SIO A， DONATO M G， FAGGIO G， et al. Spectral response of large area CVD diamond photoconductors for space applications in the vacuum UV ［J］. Diamond Relat. Mater.， 2003， 12（10-11）： 1819-1824.

TANKALA K， DEBROY T， ALARM M. Oxidation of diamond films synthesized by hot filament assisted chemical vapor deposition ［J］. J. Mater. Res.， 1990， 5（11）： 2483-2489.

WANG L J， XIA Y B， SHEN H J， et al. Infrared optical properties of diamond films and electrical properties of CVD diamond detectors ［J］. J. Phys. D： Appl. Phys.， 2003， 36（20）： 2548-2552.

BIZZARRI A， BOGANI F， BRUZZI M， et al. Luminescence and conductivity studies on CVD diamond exposed to UV light ［J］. Nucl. Instrum. Methods Phys. Res. Sec. A： Accel.， Spectrom.， Detect. Assoc. Equip.， 1999， 426（1）： 169-172.

周海洋，朱晓东，詹如娟. CVD金刚石在辐射探测领域中的应用［J］. 核技术， 2005， 28（2）： 135-140. doi: 10.3321/j.issn:0253-3219.2005.02.012http://dx.doi.org/10.3321/j.issn:0253-3219.2005.02.012

ZHOU H Y， ZHU X D， ZHAN R J. Application of CVD diamond film for radiation detection ［J］. Nucl. Tech.， 2005， 28（2）： 135-140. （in Chinese）. doi: 10.3321/j.issn:0253-3219.2005.02.012http://dx.doi.org/10.3321/j.issn:0253-3219.2005.02.012

DONATO M G， FAGGIO G， MARINELLI M， et al. High quality CVD diamond for detection applications： structural characterization ［J］. Diamond Relat. Mater.， 2001， 10（9-10）： 1788-1793.

CHEN Y C， LU Y J， LIN C N. Self-powered diamond/β-Ga2O3 photodetectors for solar-blind imaging ［J］. J. Mater. Chem. C， 2018， 6（21）： 5727-5732.

CHEN Y C， LU Y J， LIAO M Y， et al. 3D solar-blind Ga2O3 photodetector array realized via origami method ［J］. Adv. Funct. Mater.， 2019， 29（50）： 1906040-1-8.

ALVAREZ J， GODARD A， KLEIDER J P， et al. Very high UV-visible selectivity in polycrystalline CVD diamond films ［J］. Diamond Relat. Mater.， 2004， 13（4-8）： 881-885.

ZHANG Z F， LIN C N， YANG X， et al. Wafer-sized polycrystalline diamond photodetector planar arrays for solar-blind imaging ［J］. J. Mater. Chem. C， 2022， 10（16）： 6488-6496.

黄健，王林军，唐可，等. 氧化锌/金刚石薄膜异质结紫外光探测器［J］. 发光学报， 2011， 32（3）： 272-276.

HUANG J， WANG L J， TANG K， et al. Ultraviolet detector based on ZnO/diamond film heterojunction diode ［J］. Chin. J. Lumin.， 2011， 32（3）： 272-276. （in Chinese）

LI K Y， ZANG J H， YANG X， et al. Solar-blind position-sensitive detectors fabricated from β-Ga2O3/polycrystalline diamond heterojunctions ［J］. Phys. Status Solidi （RRL）， 2021， 15（10）： 2100347-1-6.

CHANG X H， WANG Y F， ZHANG X F， et al. UV-photodetector based on NiO/diamond film ［J］. Appl. Phys. Lett.， 2018， 112（3）： 032103-1-5.

LIU K， LIU B J， ZHAO J W， et al. Application of back bias to interdigital-electrode structured diamond UV detector showing enhanced responsivity ［J］. Sens. Actuators A： Phys.， 2019， 290： 222-227.

HISCOCK J， COLLINS A T. Comparison of diamond and silicon ultraviolet photodetectors ［J］. Diamond Relat. Mater.， 1999， 8（8-9）： 1753-1758.

ALVAREZ J， LIAO M Y， KOID Y. Large deep-ultraviolet photocurrent in metal-semiconductor-metal structures fabricated on as-grown boron-doped diamond ［J］. Appl. Phys. Lett.， 2005， 87（11）： 113507-1-3.

LI C， YU L M， YUAN X， et al. Ag nanorods assembled with ZnO nanowalls for near-linear high-response UV photodetectors ［J］. J. Alloys Compd.， 2020， 830： 154652-1-8.

MARINELLI M， HATTA A， ITO T， et al. Band-A emission in synthetic diamond films： a systematic investigation ［J］. Appl. Phys. Lett.， 1996， 68（12）： 1631-1633.

TERAJI T， YOSHIZAKI S， MITANI S， et al. Transport properties of electron-beam and photo excited carriers in high-quality single-crystalline chemical-vapor-deposition diamond films ［J］. J. Appl. Phys.， 2004， 96（12）： 7300-7305. doi: 10.1063/1.1805723http://dx.doi.org/10.1063/1.1805723

GRAHAM R J， MOUSTAKAS T D， DISKO M M. Cathodoluminescence imaging of defects and impurities in diamond films grown by chemical vapor deposition ［J］. J. Appl. Phys.， 1991， 69（5）： 3212-3218.

LIU J J， CHIU D Y T， MORTON D C， et al. Band gap structure and electron emission property of chemical-vapor-deposited diamond films ［J］. Solid⁃State Electron.， 2001， 45（6）： 915-919.

ZHU W， KOCHANSKI G P， JIN S， et al. Defect-enhanced electron field emission from chemical vapor deposited diamond ［J］. J. Appl. Phys.， 1995， 78（4）： 2707-2711.

LIU K， DAI B， RALCHENKO V， et al. Single crystal diamond UV detector with a groove-shaped electrode structure and enhanced sensitivity ［J］. Sens. Actuators A： Phys.， 2017， 259： 121-126.

Views

242

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Field Emission from Diamond Films by Low Voltage Driving

THE BLUE PHOTOLUMINESCENCE OF THIN DIAMOND FILMS

Diamond Solar Blind UV Detectors on Si Substrates with Graphite Electrodes

Related Author

You-ming LV

Ming FANG

Pei-jiang CAO

Yu-xiang ZENG

Shun HAN

Xi-ming RONG

Wei-liang ZHANG

Zi-yi CHEN

Related Institution

Shenzhen Key Laboratory of Special Functional Materials， Guangdong Research Center for Interfacial Engineering of Functional Materials， College of Materials Science and Engineering， Shenzhen University

Changchun Institute of Optics, Fine Mechanics and Physics, Chinese Academy of Sciences

Research Institute of Electric Communication, Tohoku University, Sendai, Japan

Department of Physics, University of Science and Technology of China, Hefei 230026

State Key Laboratory of Integrated Optoelectronics， College of Electronic Science and Engineering， Jilin University

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰