High Uniformity LED Panel-light for Plant Lighting

ZHANG Shuai; WEN Shang-sheng; MA Bing-xu; PANG Pei-yuan; CHEN Hao-wei; CAI Ming-xing; FU M

doi:10.3788/fgxb20183903.0403

您当前的位置：

首页 >

文章列表页 >

High Uniformity LED Panel-light for Plant Lighting

更新时间：2020-08-12

- High Uniformity LED Panel-light for Plant Lighting
- Chinese Journal of Luminescence Vol. 39, Issue 3, Pages: 403-413(2018)
- 作者机构：
  
  1. 华南理工大学发光材料与器件国家重点实验室,广东广州,510640
  2. 华南理工大学材料科学与工程学院,广东广州,中国,510640
- 作者简介：
- 基金信息：
  
  Supported by National Undergraduate Innovative and Entrepreneurial Training Program
- DOI：10.3788/fgxb20183903.0403
  CLC： TM923.01;TU113.6+68
- Received：08 July 2017，
  
  Revised：02 September 2017，
  
  Published Online：18 September 2017，
  
  Published：05 March 2018
- 稿件说明：
移动端阅览
张帅, 文尚胜, 马丙戌等. 适用于植物照明的高均匀度LED面光源设计[J]. 发光学报, 2018,39(3): 403-413

ZHANG Shuai, WEN Shang-sheng, MA Bing-xu etc. High Uniformity LED Panel-light for Plant Lighting[J]. Chinese Journal of Luminescence, 2018,39(3): 403-413
张帅, 文尚胜, 马丙戌等. 适用于植物照明的高均匀度LED面光源设计[J]. 发光学报, 2018,39(3): 403-413 DOI： 10.3788/fgxb20183903.0403.

ZHANG Shuai, WEN Shang-sheng, MA Bing-xu etc. High Uniformity LED Panel-light for Plant Lighting[J]. Chinese Journal of Luminescence, 2018,39(3): 403-413 DOI： 10.3788/fgxb20183903.0403.

摘要

针对目前植物照明灯具混光混色均匀度差、难以满足植物工厂高效生产作物产品的问题提出了一种高均匀度的植物面光源的设计方案。利用一种棱锥状的光学元件将LED发出的光线划分为透射、反射和直射3部分，增加了光线的耦合程度，进而提高了出光面上的混光和混色均匀度。进一步采用照度均匀度代替光量子通量密度的均匀度并且联同混色均匀度作为考察指标，利用Taguchi方法设计并进行实验，研究不同因子对光源均匀度的影响，得出实验结果后进行优化，最终获得了一个照度均匀度为92.13%、混色均匀度为89.72%的植物照明面光源。

Abstract

Traditional plant lamp's optical structure is easy with poor color uniformity and illumination uniformity. It is not good for plant growing. For this reason

a LED panel light with high color-mixed uniformity and illumination uniformity was designed. The design used a pyramidal optical element to divide the light emitted by the LED into transmission part

reflection part and direct part. This method can increase the light coupling

and improve the uniformity of the mixed light and color on light emitting surface. Furthermore

the illumination uniformity was used to instead of the photosynthetic photon flux density (PPFD) uniformity and conjuncted it with color-mixed uniformity as the examining index. Then

the Taguchi method was used to design and experiment

studying the influence of different factors on light uniformity. Finally

the results were obtained and optimized after the experimental. A plant light source with 92.13% illumination uniformity and 89.72% color-mixed uniformity was gotten.

关键词

Keywords

references

杨其长,张成波. 植物工厂概论[M]. 北京:中国农业科学技术出版社, 2004:185-186. YANG Q C, ZHANG C B. Introduction of Plant Plants[M]. Beijing:Chinese Agricultural Science and Technology Press, 2004:185-186. (in Chinese)

BOURGET C M. An introduction to light-emitting diodes[J]. Hortscience, 2008, 3(7):1944-1946.

MORROW R C. LED lighting in horticulture[J]. Hortscience, 2008, 43(7):1947-1950.

崔瑾, 徐志刚, 邸秀茹. LED在植物设施栽培中的应用和前景[J]. 农业工程学报, 2008, 24(8):249-253. CUI J, XU Z G, DI X R. Applications and prospects of light emitting diode in plant protected culture[J]. Trans. CSAE, 2008, 24(8):249-253. (in Chinese)

符民, 文尚胜, 陈浩伟, 等. 基于LSD分析LED多重光质配比对芦荟生长的影响[J]. 发光学报, 2016, 37(3):366-371. FU M, WEN S S, CHEN H W, et al.. LSD analysis based on multiple LED light quality ratio on growth of aloe[J]. Chin. J. Lumin., 2016, 37(3):366-371. (in Chinese)

陈浩伟, 文尚胜, 马丙戌, 等. 基于Taguchi法设计带有圆锥台元件的超薄直下式LED平板灯[J]. 光子学报, 2015, 44(10):14-22. CHEN H W, WEN S S, MA B X, et al.. Design of ultra-thin direct-down LED panel with tapered optical elements based on Taguchi method[J]. Acta Photon. Sinica, 2015, 44(10):14-22. (in Chinese)

马丙戌, 文尚胜, 陈颖聪, 等. 侧入式无导光板自然光平板灯[J]. 光子学报, 2015, 44(7):0722002. MA B X, WEN S S, CHEN Y C, et al.. Edge-lighting natural light flat panel light without light guide plate[J]. Acta Photon. Sinica, 2015, 44(7):0722002. (in Chinese)

马丙戌, 文尚胜, 陈颖聪, 等. 侧入式无导光板LED平板灯设计[J]. 红外与激光工程, 2016, 45(4):418001. MA B X, WEN S S, CHEN Y C, et al.. Design of edge-lighting LED flat panel light without light guide plate[J]. Infrared Laser Eng., 2016, 45(4):418001. (in Chinese)

CHEN Y C, WEN S S, SONG P C, et al.. Design of a backlight module with a freeform surface by applying the Taguchi method[J]. Chin. Opt. Lett., 2015, 13(3):032302.

彭响方, 刘婷, 陈金伟. 精密注塑成型技术的最新进展[J]. 塑料, 2004, 33(6):79-83. PENG X F, LIU T, CHEN J W. Recent development of precision injection molding technology[J]. Plastics, 2004, 33(6):79-83. (in Chinese)

宋满仓, 颜克辉. 薄壁注塑成型数值模拟技术的发展现状[J]. 塑料科技, 2006, 34(1):51-54. SONG M C, YAN K H. Present situations of numerical simulation technology for this wall injection molding[J]. Plast. Sci. Technol., 2006, 34(1):51-54. (in Chinese)

张盛桂. 基于PVT特性的精密注塑成型控制机理及设备的研究[D]. 北京:北京化工大学, 2013. ZHANG S G. Study on Control Mechanism and Equipment of Precision Injection Molding Based on Polymer PVT Property[D]. Beijing:Beijing University of Chemical Technology, 2013. (in Chinese)

FANG Y C, TZENG Y F, LI S X. Multi-objective design and extended optimization for developing a miniature light emitting diode pocket-sized projection display[J]. Opt. Rev., 2008, 15(5):241-250.

KIM K C, LEE J, KIM H J, et al.. Multiobjective optimal design for interior permanent magnet synchronous motor[J]. IEEE Trans. Magnet., 2009, 45(3):1780-1783.

TEEK S L, CHEN S X, GAO X K. Robusttorque optimization for BLDC spindle motors[J]. IEEE Trans. Ind. Electron., 2001, 48(3):656-663.

HWANG C C, LYU Y, LIU C T, et al.. Optimal design of a spm motor using genetic algorithms and Taguchi method[J]. IEEE Trans. Magnet., 2008, 44(11):4325-4328.

SILVA M M A, OLIVEIRA A L B D, OLIVEIRA-FILHO R A, et al.. Effect of blue/red LED light combination on growth and morphogenesis of saccharum officinarum plantlets in vitro[J]. SPIE, 2014, 8947(1):342-348.

LIU P, WANG H, WU R, et al.. Uniform illumination design by configuration of LEDs and optimization of LED lens for large-scale color-mixing applications[J]. Appl. Opt., 2013, 52(17):3998-4005.

WANG H C, CHIANG Y T, LIN C Y, et al.. All-reflective RGB LED flashlight design for effective color mixing[J]. Opt. Express, 2016, 24(5):266-271.

MORENO I. Illumination uniformity assessment based on human vision.[J]. Opt. Lett., 2010, 35(23):4030-4032.

SUN C C, MORENO I, LO Y C, et al.. Collimating lamp with well color mixing of red/green/blue LEDs[J]. Opt. Express, 2012, 20(1):75-84.

陈俄振, 郭震宁, 智佳军. LED扩展光源均匀照明的透镜设计[J]. 华侨大学学报(自然科学版), 2013, 34(6):632-633. CHEN E Z, GUO Z N, ZHI J J. Lens design with uniform illumination of the LED extended sources[J]. J. Huaqiao Univ.(Nat. Sci.), 2013, 34(6):632-633. (in Chinese)

孙智慧, 常军, 赵楠, 等. 一种新的用于直下式LCD背光源的LED[J]. 光学技术, 2007, 33(suppl):282-284. SUN Z H, CHANG J, ZHAO N, et al.. A novel LED for LCD backlight[J]. Opt. Tech., 2007, 33(suppl):282-284. (in Chinese)

祝振敏, 曲兴华, 梁海昱, 等. 基于发光二极管环形阵列与漫反射表面的均匀照明光源研究[J]. 光学学报, 2011, 31(1):0115001. ZHU Z M, QU X H, LIANG H Y, et al.. Uniform illumination study by light-emitting diode ring array and diffuse reflection surface[J]. Acta Opt. Sinica, 2011, 31(1):0115001. (in Chinese)

陈浩伟, 文尚胜, 马丙戌, 等. 基于光量子学的植物照明用自由曲面底板LED光源设计[J]. 光学学报, 2017, 37(2):0222001. CHEN H W, WEN S S. MA B X, et al.. Design of plant lighting LED lamp with freeform surface substrate based on light quantum theory[J]. Acta Opt. Sinica, 2017, 37(2):0222001. (in Chinese)

史晨阳, 文尚胜, 陈颖聪. 基于Taguchi方法的曲面LED阵列照度问题研究[J]. 发光学报, 2015, 36(3):348-354. SHI C Y, WEN S S, CHEN Y C. Study on curved surface LED array illumination problem based on Taguchi method[J]. Chin. J. Lumin., 2015, 36(3):348-354. (in Chinese)

史晨阳, 文尚胜, 陈颖聪. 基于Taguchi方法的曲面底板LED阵列重影问题研究[J]. 发光学报, 2015, 36(6):651-656. SHI C Y, WEN S S, CHEN Y C. Study of surface LED array multi-shadow problem based on Taguchi method[J]. Chin.J. Lumin., 2015, 36(6):651-656. (in Chinese)

兰志勇, 杨向宇, 王芳媛, 等. Taguchi方法在内嵌式正弦波永磁同步电机优化设计中的应用[J]. 电工技术学报, 2011, 26(12):37-42. LAN Z Y, YANG X Y, WANG F Y, et al.. Application for optimal designing of sinusoidal interior permanent magnet synchronous motors by using the Taguchi method[J]. Trans. China Electrotech. Soc., 2011, 26(12):37-42. (in Chinese)

KOZAI T. Plant factory in Japan-current situation and perspectives[J]. Chron. Horticult., 2013, 53(2):8-11.

汤顺青. 色度学[M]. 北京:北京理工大学出版社, 1990. TANG S Q. Colorimetry[M]. Beijing:Beijing Institute of Technology Press, 1990. (in Chinese)

FANG Y C, TZENG Y F, LI S X. Multi-objective design and extended optimization for developing a miniature light emitting diode pocket-sized projection display[J]. Opt. Rev., 2008, 15(5):241-250.

Views

132

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Highly Uniform LED Plant Light Source with Curved Reflective Surface

Design of High Illumination Uniformity Inverted LED Plant Light Source System

Design of LED Plant Lighting Source Based on Particle Swarm Optimization Algorithm Under Photons System

Design of High Uniformity LED Plant Lamp

Photoluminescence and Multifunctional Applications of NaGdMgTeO₆∶Eu³⁺ Phosphors

Related Author

LU Yun-le

WEN Shang-sheng

MA Bing-xu

JIANG Xin-yu

WU Qi-bao

JIANG Xin-yu

WEN Shang-sheng

MA Bing-xu

Related Institution

College of Material Science and Engineering, South China University of Technology

State Key Laboratory of Luminescent Materials and Devices, South China University of Technology, Guangzhou 510640, China

School of Fine Arts, South China Normal University

School of Intelligent Manufacturing and Equipment, Shenzhen Institute of Information Technology

College of Material Science and Engineering, South China University of Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰