Laser Lighting Device Based on YAG: Ce3+ Phosphor Composite Eu3+ Doped Phosphor-in-glasses

ZHENG Fei; MAO Yun-wei; YANG Bo-bo; ZOU Jun; LIU Yi-ming; XIE Yu; TANG Zi-rui; KU Li-ming; S

doi:10.3788/fgxb20194007.0842

您当前的位置：

首页 >

文章列表页 >

Laser Lighting Device Based on YAG: Ce³⁺ Phosphor Composite Eu³⁺ Doped Phosphor-in-glasses

Synthesis and Properties of Materials | 更新时间：2020-08-12

- Laser Lighting Device Based on YAG: Ce³⁺ Phosphor Composite Eu³⁺ Doped Phosphor-in-glasses
- Chinese Journal of Luminescence Vol. 40, Issue 7, Pages: 842-848(2019)
- 作者机构：
  
  1. 上海应用技术大学理学院, 上海 201418
  2. 上海应用技术大学材料科学与工程学院, 上海 201418
  3. 有研半导体材料有限公司, 北京 100088
  4. 深圳市晶台股份有限公司, 广东深圳 518105
  5. 浙江美科电器有限公司, 浙江绍兴 312000
- 作者简介：
- 基金信息：
  
  Supported by Science and Technology Planning Project of Zhejiang Province (2018C0104
- DOI：10.3788/fgxb20194007.0842
  CLC： TN365
- Received：17 July 2018，
  
  Revised：22 September 2018，
  
  Published Online：11 October 2018，
  
  Published：05 July 2019
- 稿件说明：
移动端阅览
郑飞, 茅云蔚, 杨波波等. 基于YAG∶Ce3+荧光粉复合Eu3+掺杂荧光玻璃的激光照明器件[J]. 发光学报, 2019,40(7): 842-848

ZHENG Fei, MAO Yun-wei, YANG Bo-bo etc. Laser Lighting Device Based on YAG: Ce3+ Phosphor Composite Eu3+ Doped Phosphor-in-glasses[J]. Chinese Journal of Luminescence, 2019,40(7): 842-848
郑飞, 茅云蔚, 杨波波等. 基于YAG∶Ce3+荧光粉复合Eu3+掺杂荧光玻璃的激光照明器件[J]. 发光学报, 2019,40(7): 842-848 DOI： 10.3788/fgxb20194007.0842.

ZHENG Fei, MAO Yun-wei, YANG Bo-bo etc. Laser Lighting Device Based on YAG: Ce3+ Phosphor Composite Eu3+ Doped Phosphor-in-glasses[J]. Chinese Journal of Luminescence, 2019,40(7): 842-848 DOI： 10.3788/fgxb20194007.0842.

摘要

采用结晶法和低温共烧结法制备了Eu

掺杂的Y

:Ce

荧光玻璃，对制备出的样品进行能量色散X射线谱和光致发光光谱测试，表明稀土离子Eu

与YAG:Ce

荧光粉已掺入荧光玻璃。掺杂不同含量Eu

的YAG:Ce

荧光玻璃封装成的激光照明器件在驱动电流100 mA下，经过STC-4000快速光谱仪和PMS-80可见光谱分析系统测试，掺杂质量分数1% YAG:Ce

复合质量分数9%的Eu

的荧光玻璃封装的激光照明器件发光效率为267.1 lm/W。激光照明器件随着电流的增加，其显色指数逐渐增大，但增加幅度较小。

Abstract

The Eu

doped Y

:Ce

phosphor-in-glasses(PIGs) was prepared by crystallization and low temperature co-sintering. The prepared samples were tested by energy dispersive X-ray and photoluminescence spectroscopy

indicating that the rare earth ions Eu

and YAG:Ce

phosphors have been incorporated into the PIG. YAG:Ce

PIG with different content of Eu

is packaged in a laser illumination device with a driving current of 100 mA. It is tested by STC-4000 fast spectrometer and PMS-80 visible spectrum analysis system

doping mass fraction 1% YAG:Ce

composite mass fraction 9% Eu

phosphor-in-glasses encapsulated laser lighting device luminous efficacy is 267.1 lm/W. As the current of laser illumination devices increases

the color rendering index increases gradually

but the increase is small.

关键词

Keywords

references

TSAO J Y. Solid-state lighting:lamps,chips,and materials for tomorrow[J]. IEEE Circuits Devices Mag., 2004,20(3):28-37.

史光国. 半导体发光二级管及固体照明[M]. 北京:科学出版社, 2007. SHI G G. Semiconductor Light-emitting Diodes and Solid-state Lighting [M]. Beijing:Science Press, 2007. (in Chinese)

STEIGERWALD D A,BHAT J C,COLLINS D, et al.. Illumination with solid state lighting technology[J]. IEEE J. Sel. Top. Quantum Electron., 2002,8(2):310-320.

徐时清,金尚忠,王宝玲,等. 固体照明光源-白光LED的研究进展[J]. 中国计量学院学报, 2006,17(3):188-191. XU S Q,JIN S Z,WANG B L, et al.. Solid state lighting-recent progress in research of white light emitting diodes[J]. J. China Jiliang Univ., 2006,17(3):188-191. (in Chinese)

肖芬. 紫外激发白光LED荧光粉的制备及发光特性研究[D]. 广州:华南理工大学, 2011. XIAO F. Preparation and Luminescence Properties of Phosphors for UV Excited White Light-emitting Diodes[D]. Guangzhou:South China University of Technology, 2011. (in Chinese)

陶岳彬. GaN基大功率蓝光LED的MOCVD生长和改善效率骤降特性的研究[D]. 北京:北京大学, 2011. TAO Y B. Research on MOCVD Growth and Improvement Efficiency Drop Characteristics of GaN-based High Power Blue LEDs[D]. Beijing:Peking University, 2011. (in Chinese)

KOECHNER W. Solid-state Laser Engineering[M]. New York:Springer, 2006.

RAZUM N J. Laser physics[J]. Facial Plast. Surg., 1989,6(3):137-143.

THOMAS G,ISAACS R. Basic principles of lasers[J]. Anaesth. Intensive Care Med., 2011,12(12):574-577.

HERREROS D N,FANG X. Laser ignition of elastomer-modified cast double-base (EMCDB) propellant using a diode laser[J]. Opt. Laser Technol., 2017,89:21-26.

SELIMIS A,MIRONOV V,FARSARI M. Direct laser writing:principles and materials for Scaffold 3D printing[J]. Microelectron. Eng., 2015,132:83-89.

RODRIGUES G C,DUFLOU J R. Opportunities in laser cutting with direct diode laser configurations[J]. CIRP Ann., 2017,66(1):245-248.

ABSTEN G T. Physics of light and lasers[J]. Obstet. Gynecol. Clin. North Am., 1991,18(3):407-427.

LIU H,SUN C L,WANG W S, et al.. Design of a LCOS laser projector[J]. Optik, 2015,126(15-16):1483-1486.

NARUKAWA Y,NAGAHAMA S I,TAMAKI H, et al.. Development of high-luminance white light source using GaN-based light emitting devices[J]. 應用物理, 2005,74(11):1423-1432.

KOZAKI T,NAGAHAMA S,MUKAI T. Recent progress of high-power GaN-based laser diodes[C]. Proceedings Volume 6485,Novel In-plane Semiconductor Lasers VI,San Jose,California,USA, 2007,6485:648503.

DENAULT K A,CANTORE M,NAKAMURA S, et al.. Efficient and stable laser-driven white lighting[J]. AIP Adv., 2013,3(7):072107-1-7.

WIERERJR J J,TSAO J Y,SIZOV D S. The potential of Ⅲ-nitride laser diodes for solid-state lighting[J]. Phys. Status Solidi C, 2014,11(3-4):674-677.

许礼强. 基于激光远程激发荧光粉(LARP)技术的新型白光光源研究[D]. 深圳:深圳大学, 2015. XU L Q. Study on New White Light Source base on LARP Technology[D]. Shenzhen:Shenzhen University, 2015. (in Chinese)

王子明,黄笑彤,杨波波,等. 低温共烧结制备Lu2.94-xYx Al5O12:0.06Ce荧光玻璃的研究[J]. 光电技术应用, 2017,32(6):39-43. WANG Z M,HUANG X T,YANG B B, et al.. Preparation of Lu2.94-xYx Al5O12:0.06Ce phosphor in glass by low-temperature co-sintering method[J]. Electro-Opt. Technol. Appl., 2017,32(6):39-43. (in Chinese)

KINOSHITA J,IKEDA Y,TAKEDA Y, et al.. Suppressed speckle contrast of blue light emission out of white lamp with phosphors excited by blue laser diodes for high-brightness lighting applications[J]. Opt. Rev., 2012,19(6):427-431.

武传雷. YAG荧光粉的制备和性能研究[D]. 上海:上海师范大学, 2013. WU C L. Preparation and Properties of YAG Phosphors[D]. Shanghai:Shanghai Normal University, 2013. (in Chinese)

Views

207

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰