Research and Design of High Power Concentrator Module System

HUANG Rui; GUO Li-min; LIU You-qiang; WANG Cong-cong; ZHAO Ming; ZHANG Xiao-ning; ZHANG Ho

doi:10.3788/fgxb20183907.0974

您当前的位置：

首页 >

文章列表页 >

Research and Design of High Power Concentrator Module System

更新时间：2020-08-12

- Research and Design of High Power Concentrator Module System
- Chinese Journal of Luminescence Vol. 39, Issue 7, Pages: 974-982(2018)
- 作者机构：
  
  北京工业大学激光工程研究院北京,100124
- 作者简介：
- 基金信息：
- DOI：10.3788/fgxb20183907.0974
  CLC： TN29
- Received：03 November 2017，
  
  Revised：03 January 2018，
  
  Published Online：01 February 2018，
  
  Published：05 July 2018
- 稿件说明：
移动端阅览
黄瑞, 郭丽敏, 刘友强等. 高倍聚光模组系统研究与设计[J]. 发光学报, 2018,39(7): 974-982

HUANG Rui, GUO Li-min, LIU You-qiang etc. Research and Design of High Power Concentrator Module System[J]. Chinese Journal of Luminescence, 2018,39(7): 974-982
黄瑞, 郭丽敏, 刘友强等. 高倍聚光模组系统研究与设计[J]. 发光学报, 2018,39(7): 974-982 DOI： 10.3788/fgxb20183907.0974.

HUANG Rui, GUO Li-min, LIU You-qiang etc. Research and Design of High Power Concentrator Module System[J]. Chinese Journal of Luminescence, 2018,39(7): 974-982 DOI： 10.3788/fgxb20183907.0974.

摘要

聚光系统的聚光效率和能量均匀性直接影响单位模组的发电效率。本文研究设计出高倍聚光模组系统，该系统主要包括菲涅耳透镜和球冠平顶微棱镜。采用中心波长修正法进行菲涅耳透镜的设计，并通过Zemax仿真模拟设计出球冠平顶微棱镜。最后通过Zemax模拟，决定选取两侧面夹角的角度为117，平顶到球面的间隔

为0.2 mm，球冠平顶微棱镜的曲率半径

为10 mm。聚光系统整体的聚光效率达99.8%，能量均匀度为0.812，并进行实验验证，得出实际聚光效率为83.1%。

Abstract

The concentrating efficiency and the energy uniformity of the concentrating system directly influence the generation efficiency of the unit module. In this paper

a high power condensing module system was studied. The system included a Fresnel lens and flat spherical micro prism. The Fresnel lens was designed by central wavelength correction method and through Zemax simulation

and the design of spherical flat lens was established. Finally

through the Zemax simulation

it is decided that the angle between the two sides is selected to be 117

the distance

between the flat top and the spherical surface is 0.2 mm

and the curvature radius

of the spherical dome microprism is 10 mm. The condensing system as a whole has a condensing efficiency of 99.8% and an energy uniformity of 0.812. Experimental results show that the actual condensing efficiency is 83.1%.

关键词

Keywords

references

PREZ-HIGUERAS P, FERNNDEZ E F. High Concentrator Photovoltaics:Fundamentals, Engineering and Power Plants[M]. Berln:Springer International Publishing, 2015.

TALAVERA D L, FERRER-RODRGUEZ J P, PREZ-HIGUERAS P, et al.. A worldwide assessment of levelised cost of electricity of HCPV systems[J]. Energy Convers Manage, 2016, 127:679-692.

梁齐兵, 舒碧芬, 孙丽娟, 等. 三结太阳电池在非均匀光照下光斑强度和覆盖比率的优化研究[J]. 物理学报,2014, 63(16):168801. LIANG Q B, SHU B F, SUN L J, et al.. Optimization of spot intensity and coverage ratio of three-junction solar cells under non-uniform illumination[J]. Acta Phys. Sinica, 2014, 63(16):168801. (in Chinese)

FU L, LEUTZ R, ANNEN H P. Evaluation and comparison of different designs and materials for Fresnel lens-based solar concentrators[J]. SPIE, 2011, 8124:81240E1-6.

郭丽敏, 卫明, 杨光辉, 等. 高倍聚光光伏可拆卸型二次反射镜设计与研究[J]. 红外与激光工程, 2013, 42(S2):422-425. GUO L M, WEI M, YANG G H, et al.. Design and research of high-power condenser photovoltaic detachable secondary mirror[J]. Infrared Laser Eng., 2013, 42(S2):422-425. (in Chinese)

杨光辉, 刘友强, 尧舜, 等. 聚光模组二次光学元件优化设计与研究[J]. 光学学报, 2015, 35(3):322006. YANG G H, LIU Y Q, YAO S, et al.. Optimized design and research of secondary optics for concentrating modules[J]. Acta Opt. Sinica, 2015, 35(3):322006. (in Chinese)

闫素英, 李洪阳, 马靖, 等. 菲涅尔高倍聚光PV/T系统的均光优化与热特性研究[J]. 应用科技, 2016(4):21-26. YAN S Y, LI H Y, MA J, et al.. Study on the optimization of uniform light and thermal properties of fresnel high-power concentrating PV/T system[J]. Appl. Sci. Technol., 2016(4):21-26. (in Chinese)

杨光辉. 密集矩阵高倍聚光光伏模组关键技术研究[D]. 北京:北京工业大学, 2015. YANG G H. Research on Key Technologies of Dense Matrix High Power Concentrating Photovoltaic Modules[D]. Beijing:Beijing University of Technology, 2015. (in Chinese)

曹玉岩, 王志臣, 周超, 等. 光学元件挠性支撑结构广义建模及优化设计[J]. 光学精密工程, 2016, 24(11):2793-2803. CAO Y Y, WANG Z C, ZHOU C, et al.. Generalized modeling and optimum design of flexible support structure for optical components[J]. Opt. Precision Eng., 2016, 24(11):2793-2803. (in Chinese)

王红睿, 李会端, 方伟. 航天太阳敏感器的应用与发展[J]. 中国光学, 2013, 6(4):481-489. WANG H R, LI H D, FANG W. Application and development of space solar sensors[J]. Chin. Opt., 2013, 6(4):481-489. (in Chinese)

刘华, 卢振武, 朱瑞, 等. 聚光光伏系统的发展及未来趋势[J]. 中国光学, 2008, 1(Z1):49-56. LIU H, LU Z W, ZHU R, et al.. The development and future trends of concentrated photovoltaic systems[J]. Chin. Opt., 2008, 1(Z1):49-56. (in Chinese)

胡雪花, 李福山, 吴朝兴, 等. 基底温度对喷涂技术制备大面积有机太阳能电池性能的影响[J]. 发光学报, 2013, 34(12):1641-1645. HU X X, LI F S, WU C X, et al.. Effects of substrate temperature on the performance of large area organic solar cells fabricated by spraying techniques[J]. Chin. J. Lumin., 2013, 34(12):1641-1645. (in Chinese)

叶金晶, 周健, 卞洁玉, 等. 晶硅太阳电池原位光老化及热致输运机理[J]. 光子学报, 2016, 45(9):111-116. YE J J, ZOU J, YU J Y, et al.. In-situ photoaging and heat-induced transport mechanism of crystalline silicon solar cells[J]. Acta Photon. Sinica, 2016, 45(9):111-116. (in Chinese)

李梦庆, 张雷, 李宗轩, 等. 空间平面反射镜组件销钉预紧的非线性分析[J]. 光子学报, 2016, 45(2):140-145. LI M Q, ZHANG L, LI Z X, et al.. Nonlinear analysis of pin pre-tightening of spatial plane mirror components[J]. Acta Photon. Sinica, 2016, 45(2):140-145. (in Chinese)

许贺菊, 张彬, 张瑜, 等. 基于薄膜退火的MoS2/SiO2/Si异质结太阳能电池光伏性能提高[J]. 光学精密工程, 2017, 25(3):597-602. XU H J, ZHANG B, ZHANG Y, et al.. Photovoltaic performance improvement of MoS2/SiO2/Si heterojunction solar cells based on thin film annealing[J]. Opt. Precision Eng., 2017, 25(3):597-602. (in Chinese)

Views

324

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Thermal Analysis and Fiber Coupling Simulation Design of Multi-single Emitters Stacked Semiconductor Laser

Laser Power Supply Technology in Pulse Electric Field Test

Design of Photoelectric Coupler Module with Optical Fiber Embedded in Flexible Printed Circuit Board

Design of 915 nm/974 nm Single-emitter Laser Diode Fiber-coupled Module

Fiber Coupling of Multi-single Emitters Diode Lasers Based on Curved Surface Spatial Combination

Related Author

Li XU

Wei-yan LI

Yan LI

He ZHANG

Xiao-hui MA

Lin-lin SHI

Jiao-jiao WANG

WANG Jia

Related Institution

State Key Laboratory of High Power Semiconductor Laser, Changchun University of Science and Technology

Army Armored Force Academy

National Key Laboratory of Science and Technology on Strong Electromagnetic Environment Simulation and Protection, Army Engineering University

Key Laboratory of Guangxi Manufacturing System and Advanced Manufacturing Technology

School of Mechatronic Engineering, Guilin University of Electronic Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰