Research Progress in Fabrication and Application of Crystalline Rubrene Thin Film

REN Wei; ZHANG Pei-pei; WANG Li-juan; SUN Li-jing

doi:10.3788/fgxb20183904.0494

您当前的位置：

首页 >

文章列表页 >

Research Progress in Fabrication and Application of Crystalline Rubrene Thin Film

更新时间：2020-08-12

- Research Progress in Fabrication and Application of Crystalline Rubrene Thin Film
- Chinese Journal of Luminescence Vol. 39, Issue 4, Pages: 494-506(2018)
- 作者机构：
  
  1. 吉林建筑大学,吉林长春,130118
  2. 长春工业大学化学工程学院,吉林长春,130012
- 作者简介：
- 基金信息：
  
  Supported by National Natural Science Foundation of China (21403016);Scientific Re
- DOI：10.3788/fgxb20183904.0494
  CLC： O649
- Received：23 September 2017，
  
  Revised：26 October 2017，
  
  Published：05 April 2018
- 稿件说明：
移动端阅览
任伟, 张沛沛, 王丽娟等. 红荧烯晶体薄膜的制备及应用研究进展[J]. 发光学报, 2018,39(4): 494-506

REN Wei, ZHANG Pei-pei, WANG Li-juan etc. Research Progress in Fabrication and Application of Crystalline Rubrene Thin Film[J]. Chinese Journal of Luminescence, 2018,39(4): 494-506
任伟, 张沛沛, 王丽娟等. 红荧烯晶体薄膜的制备及应用研究进展[J]. 发光学报, 2018,39(4): 494-506 DOI： 10.3788/fgxb20183904.0494.

REN Wei, ZHANG Pei-pei, WANG Li-juan etc. Research Progress in Fabrication and Application of Crystalline Rubrene Thin Film[J]. Chinese Journal of Luminescence, 2018,39(4): 494-506 DOI： 10.3788/fgxb20183904.0494.

摘要

红荧烯具有导电性好、吸收系数高等优良的荧光特性和半导体特性，是目前报道的单晶迁移率最高的材料，在有机光电器件中有很好的发展前景，受到科研人员的广泛关注。目前国内外主要采用真空蒸镀方法和溶液加工方法制备红荧烯晶体薄膜，采用各种制备工艺来提高红荧烯薄膜质量。本文在系统介绍红荧烯晶体薄膜制备工艺研究进展的基础上，归纳总结了掺杂种类/聚合物浓度、后处理工艺/实验温度等对红荧烯晶体性能的影响，简要概述了红荧烯薄膜在有机光电子器件应用研究中所取得的研究成果，最后展望了基于红荧烯晶体薄膜的光电器件的发展趋势。

Abstract

Rubrene receives extensive attention by researchers due to its excellent fluorescence and semiconductor properties of good electrical conductivity and high absorption coefficient

it has the highest mobility of single-crystalline

and will have a great development prospect in organic optoelectronic devices. At present

vacuum evaporation and solution-processing methods are mainly used to fabricate crystalline rubrene thin film by domestic and international scholars

various preparation processes are used to improve the quality of rubrene thin films. In this article

the influence of doping type

polymer concentration

post-treatment process and experimental temperature on the properties of rubrene crystal are summarized based on the systematic introduction about research progress in the fabrication process of rubrene thin films. The research achievements of rubrene thin films in the application of organic optoelectronic devices are summarized briefly. At last

the development trend of the optoelectronic devices based on the crystalline rubrene thin film is prospected.

关键词

Keywords

references

YAMAGISHI M, TAKEYA J, TOMINARI Y, et al.. High-mobility double-gate organic single-crystal transistors with organic crystal gate insulators[J]. Appl. Phys. Lett., 2007, 90(18):182117.

MATSUKAWA T, TAKAHASHI Y, TOKIYAMA T, et al.. Solution growth of rubrene single crystals using various organic solvents[J]. Jpn. J. Appl. Phys., 2008, 47(12):8950-8954.

NAJAFOV H, LYU B, BIAGGIO I, et al.. Two mechanisms of exciton dissociation in rubrene single crystals[J]. Appl. Phys. Lett., 2010, 96(18):183302.

YILDIZ A, KISSINGER P T, REILLEY C N. Triplet triplet fluorescence of rubrene in solution[J]. J. Chem. Phys., 1968, 49(3):1403-1406.

SEO J H, PARK D S, CHO S W, et al.. Buffer layer effect on the structural and electrical properties of rubrene-based organic thin-film transistors[J]. Appl. Phys. Lett., 2006, 89(16):163505.

ZIMMERLING T, BATLOGG B. Improving charge injection in high-mobility rubrene crystals:from contact-limited to channel-dominated transistors[J]. J. Appl. Phys., 2014, 115(16):164511.

KIM J S, KAJⅡ H, OHMORI Y. Characteristics of optical response in red organic light-emitting diodes using two dopant system for application to the optical link devices[J]. Thin Solid Films, 2006, 499(1-2):343-348.

JIA W, CHEN Q, CHEN L, et al.. Molecular spacing modulated conversion of singlet fission to triplet fusion in rubrene-based organic light-emitting diodes at ambient temperature[J]. J. Phys. Chem. C, 2016, 120(15):873-878.

CAO J, ZHAN Z, HOU L, et al.. Optical modeling of organic solar cells based on rubrene and C70[J]. Appl. Opt., 2012, 51(23):5718.

KAFER D, RUPPEL L, WITTE G, et al.. Role of molecular conformations in rubrene thin film growth[J]. Phys. Rev. Lett., 2005, 95(16):166602.

GAUR A, KUMAR P. Studies on stability of bi-functional P3HT:PCBM:rubrene optoelectronic devices[J]. Appl. Phys. A, 2013, 111(3):877-886.

HE X, CHOW W, LIU F, et al.. MoS2/rubrene van der Waals heterostructure:toward ambipolar field-effect transistors and inverter circuits[J]. Small, 2017, 13(2):1602558.

SEO J H, PEDERSEN T M, CHANG G S, et al.. Probing interfacial characteristics of rubrene/pentacene and pentacene/rubrene bilayers with soft X-ray spectroscopy[J]. J. Phys. Chem. B, 2007, 111(32):9513-9518.

DING H, GAO Y. Rubrene electronic structure, interface energy level alignment, and growth dynamics[J]. SPIE, 2010, 7778:77780J.

FIELITZ T R, HOLMES R J. Crystal morphology and growth in annealed rubrene thin films[J]. Cryst.Growth Design, 2016, 16(8):4720-4726.

JURCHESCU O D, MEETSMA A, PALSTRA T T. Low-temperature structure of rubrene single crystals grown by vapor transport[J]. Acta Crystallograph., 2006, 62(Pt 2):330-334.

MATSUKAWA T, YOSHIMURA M, SASAI K, et al.. Growth of thin rubrene single crystals from 1-propanol solvent[J]. J. Cryst. Growth, 2010, 312(2):310-313.

DU C, WANG W, LI L, et al.. Growth of rubrene crystalline thin films using thermal annealing on DPPC LB monolayer[J]. Org. Electron. Phys. Mater. Appl., 2013, 14(10):2534-2539.

SU Y, LIU J, ZHENG L, et al.. Polymer assisted solution-processing of rubrene spherulites via solvent vapor annealing[J]. RSC Adv., 2012, 2(13):5779-5788.

LUO L, LIU G, HUANG L, et al.. Solution-based patterned growth of rubrene nanocrystals for organic field effect transistors[J]. Appl. Phys. Lett., 2009, 95(26):263312.

HUANG L, LIAO Q, SHI Q, et al.. Rubrene micro-crystals from solution routes:their crystallography, morphology and optical properties[J]. J. Mater. Chem., 2009, 20(1):159-166.

YAMAGISHI M, TAKEYA J, TOMINARI Y, et al.. Very high-mobility organic single-crystal transistors with in-crystal conduction channels[J]. Appl. Phys. Lett., 2007, 90(10):102120.

ABDERRAHIM Y. Recent trends in crystal engineering of high-mobility materials for organic electronics[J]. Polym. Sci., 2014, 56(1):1811-2382.

HAEMORI M, YAMAGUCHI J, YAGINUMA S, et al.. Fabrication of highly oriented rubrene thin films by the use of atomically finished substrate and pentacene buffer layer[J]. Jpn. J. Appl. Phys., 2005, 44(6):3740-3742.

WANG L, YAN C, ZHANG L, et al.. Mechanism of rubrene thin film growth using -quaterthiophene inducing layer at low temperature[J]. Thin Solid Films, 2017, 621:131-136.

JEONG S H, CHOI J M, HWANG D K, et al.. Enhanced mobility of rubrene thin-film transistors with a polymer dielectric on plastic substrate[J]. Electrochem. Solid-State Lett., 2007, 10(11):H321-H323.

WANG C, HSIEH C, HWANG J. Flexible organic thin-film transistors with silk fibroin as the gate dielectric[J]. Adv. Mater., 2011, 23(14):1630-1634.

RAIMONDO L, FUMAGALLI E, MORET M, et al.. Epitaxial interfaces in rubrene thin film heterostructures[J]. J. Phys. Chem. C, 2013, 117(27):13981-13988.

FUSELLA M A, YANG S, ABBASI K, et al.. Use of an underlayer for large area crystallization of rubrene thin films[J]. Chem. Mater., 2017, 29(16):6666-6673.

LUO Y, BRUN M, RANNOU P, et al.. Growth of rubrene thin film, spherulites and nanowires on SiO2[J]. Phys. Stat. Sol., 2007, 204(6):1851-1855.

YOON Y, KIM S, LEE H, et al.. Characterization of rubrene polycrystalline thin film transistors fabricated using various heat-treatment conditions[J]. Thin Solid Films, 2011, 519(16):5562-5566.

CAMPIONE M, MORET M, RAIMONDO L, et al.. Kinetic phase selection of rubrene heteroepitaxial domains[J]. J. Phys. Chem. C, 2009, 113(49):20927-20933.

KARADENIZ S, BAR1S B, YVKSEL F, et al.. Analysis of electrical properties of Al/p-Si Schottky contacts with and without rubrene layer[J]. Synth. Met., 2013, 168(1):16-22.

TUGLUOGLU N, BARIS B, GUREL H, et al.. Investigation of optical band gap and device parameters of rubrene thin film prepared using spin coating technique[J]. J. Alloys Compd., 2014, 582(2):696-702.

HU X, WANG Z, ZHU X, et al.. Foreign particle promoted crystalline nucleation for growing higquality ultrathin rubrene films[J]. Small, 2016, 12(30):4086-4092.

ZHU L, GAO Y, LI X, et al.. Development of high-k hafnium-aluminum oxide dielectric films using sol-gel process[J]. J. Mater. Res., 2014, 29(15):1620-1625.

STINGELINSTUTZMANN N, SMITS E, WONDERGEM H, et al.. Organic thin-film electronics from vitreous solution-processed rubrene hypereutectics[J]. Nat. Mater., 2005, 4(8):601-606.

JO P S, DUONG D T, PARK J, et al.. Control of rubrene polymorphs via polymer binders:applications in organic field-effect transistors[J]. Chem. Mater., 2015, 27(11):3979-3987.

YUAN Y, GIRI G, AYZNER A L, et al.. Ultra-high mobility transparent organic thin film transistors grown by an off-centre spin-coating method[J]. Nat. Commun., 2014, 5(1):3005.

PARK S W, CHOI J M, LEE K H, et al.. Amorphous-to-crystalline phase transformation of thin film rubrene[J]. J. Phys. Chem. B, 2010, 114(17):5661-5665.

LEE H M, KIM J J, CHOI J H, et al.. In situ patterning of high-quality crystalline rubrene thin films for high-resolution patterned organic field-effect transistors[J]. ACS Nano, 2011, 5(10):8352.

DICKEY K C, ANTHONY J E, LOO Y L. Improving organic thin-film transistor performance through solvent-vapor annealing of solution-processable triethylsilylethynyl anthradithiophene[J]. Adv. Mater., 2006, 18(13):1721-726.

QIAN X, WANG T, YAN D. Transparent organic thin-film transistors based on high quality polycrystalline rubrene film as active layers[J]. Org. Electron., 2013, 14(4):1052-1056.

CHANG H, LI W, TIAN H, et al.. High performance of rubrene thin film transistor by weak epitaxy growth method[J]. Org. Electron., 2015, 20(9):43-48.

KIM J, LEE H, PARKJ, et al.. Patterning of rubrene thin-film transistors based on electron irradiation of a polystyrene dielectric layer[J]. J. Mater. Chem. C, 2015, 3(11):2650-2655.

DING G Y, WANG J, JIANG W L, et al.. White organic light-emitting devices based on fac tris(2-phenylpyridine) iridium sensitized 5,6,11,12-tetraphenylnap-hthacene[J]. Optoelectron. Lett., 2008, 4(3):0205-0208.

ZHANG Z L, JIANG X Y, XU S H, et al.. The effect of rubrene as a dopant on the efficiency and stability of organic thin film electroluminescent devices[J]. J. Phys. D, 1998, 31(1):32-35.

WANG X, WANG R, ZHOU D, et al.. Study of organic light-emitting diodes with exciplex and non-exciplex forming interfaces consisting of an ultrathin rubrene layer[J]. Synth. Met., 2016, 214:50-55.

LIU Y, WU X, XIAO Z, et al.. Highly efficient tandem OLED based on C60/rubrene:MoO3, as charge generation layer and LiF/Al as electron injection layer[J]. Appl. Surf. Sci., 2017, 413:302-307.

PANDEY A K, NUNZI J M. Impact of selective thermal annealing on rubrene-C60, heterojunction solar cells[J]. Synth. Met., 2012, 162(23):2171-2175.

HUANG J, YU J, WANG W, et al.. Organic solar cells with a multicharge separation structure consisting of a thin rubrene fluorescent dye for open circuit voltage enhancement[J]. Appl. Phys. Lett., 2011, 98(2):023301.

VERREET B, HEREMANS P, STESMANS A, et al.. Microcrystalline organic thin-film solar cells[J]. Adv. Mater., 2013, 25(38):5504-5507.

JIN F, SU Z, CHU B, et al.. Interface engineering of organic schottky barrier solar cells and its application in enhancing performances of planar heterojunction solar cells[J]. Sci. Rep., 2016, 6(6):26262.

Views

433

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Research Status and Strategy of Pure Organic Room Temperature Phosphorescent Materials

Prospect and Challenge of Polymers Featuring Aggregation-induced Emission Characteristics

Effect of Fabrication Technology of Polymer Optical Waveguide Amplifier Based on NaYF₄:Er³⁺,Yb³⁺ Nanocrystals on Device Performance

Fabrication of Zirconia Dielectric Layer by Spin Coating and Its Application in Thin Film Transistor

Rubrene Crystal Films Using PVP as Interface Modification Layer Fabricated by Solution Methods

Related Author

ZHENG Xian

YANG Chao-long

An-jun QIN

Rong HU

XING Gui-chao

HUANG Ya-li

ZHANG Mei-ling

WANG Xi-bin

Related Institution

School of Material Science and Engineering， Chongqing University of Technology

State Key Laboratory of Luminescent Materials and Devices, Guangdong Provincial Key Laboratory of Luminescence from Molecular Aggregates, School of Materials Science and Engineering, South China University of Technology

Engineering Laboratory on Polymeric Waveguide Components of Optics Communications of Jilin Province, State Key Laboratory of Integrated Optoelectronics, College of Electronic Science and Engineering, Jilin University

College of Electronic Engineering, South China Agricultural University

Institute of Polymer Optoelectronic Materials and Devices, State Key Laboratory of Luminescent Materials and Devices, Material College, South China University of Technology

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰