Preparation and Gas Sensing Characteristics of ZnO Nanowire Arrays Surface-decorated by Pd Particles

YANG Zhi-bo; CAO Pei-jiang; HAN Shun; LIU Xin-ke; LIU Wen-jun; JIA Fang; ZENG Yu-xiang; XU

doi:10.3788/fgxb20173808.1033

您当前的位置：

首页 >

文章列表页 >

Preparation and Gas Sensing Characteristics of ZnO Nanowire Arrays Surface-decorated by Pd Particles

更新时间：2020-08-12

- Preparation and Gas Sensing Characteristics of ZnO Nanowire Arrays Surface-decorated by Pd Particles
- Chinese Journal of Luminescence Vol. 38, Issue 8, Pages: 1033-1038(2017)
- 作者机构：
  
  深圳大学材料学院, 广东省功能材料界面工程技术研究中心, 深圳市特种功能材料重点实验室,广东深圳,518060
- 作者简介：
- 基金信息：
  
  Supported by National Natural Science Foundation of China (51371120, 51302174, 61504
- DOI：10.3788/fgxb20173808.1033
  CLC： O484.4;TP212.2
- Received：18 December 2016，
  
  Revised：10 February 2017，
  
  Published：05 August 2017
- 稿件说明：
移动端阅览
杨志博, 曹培江, 韩舜等. Pd颗粒表面修饰ZnO纳米线阵列的制备及其气敏特性[J]. 发光学报, 2017,38(8): 1033-1038

YANG Zhi-bo, CAO Pei-jiang, HAN Shun etc. Preparation and Gas Sensing Characteristics of ZnO Nanowire Arrays Surface-decorated by Pd Particles[J]. Chinese Journal of Luminescence, 2017,38(8): 1033-1038
杨志博, 曹培江, 韩舜等. Pd颗粒表面修饰ZnO纳米线阵列的制备及其气敏特性[J]. 发光学报, 2017,38(8): 1033-1038 DOI： 10.3788/fgxb20173808.1033.

YANG Zhi-bo, CAO Pei-jiang, HAN Shun etc. Preparation and Gas Sensing Characteristics of ZnO Nanowire Arrays Surface-decorated by Pd Particles[J]. Chinese Journal of Luminescence, 2017,38(8): 1033-1038 DOI： 10.3788/fgxb20173808.1033.

摘要

采用化学气相沉积（CVD）方法在SiO

/Si衬底生长了ZnO纳米线阵列，纳米线长约为15 m，直径为100~500 nm。通过改变溅射沉积时间（0~150 s），在ZnO纳米线表面包覆了不同厚度的Pd薄膜。在Ar气氛中，经800℃高温退火后，制备出Pd颗粒表面修饰的ZnO纳米线阵列并对其进行了气敏测试。对于乙醇而言，所有传感器最佳工作温度均为280℃。溅射时间的增加（3~10 s）导致ZnO纳米线表面Pd纳米颗粒数量及尺寸增加，传感器响应值由2.0增至3.6。过长的溅射时间（30~150 s）将导致Pd颗粒尺寸急剧增大甚至形成连续膜，传感器响应度显著降低。所有传感器对H

均表现出相对较好的选择性，传感器具有较好的响应-恢复特性和稳定性。最后，探讨了Pd颗粒表面修饰对ZnO纳米线阵列气敏传感器气敏特性的影响机制。

Abstract

ZnO nanowire (NW) arrays were synthesized by chemical vapor deposition (CVD) method on SiO

/Si substrate. The Pd films with different sputtering time (0-150 s) were uniformly deposited on the surface of ZnO NWs and converted to Pd particles by annealing treatment at 800℃ in Ar gas

and then the gas sensing measurement was performed. The length of the NW is about 15 m and the diameter is 100-500 nm. For ethanol gas

the optimal working temperature of all gas sensors is 280℃. The increase of the sputtering time (from 3 to 10 s) induces the increase of the number and size of Pd particles

and the response of gas sensor raises from 2.0 to 3.6. Further increase of the sputtering time (from 30 to 150 s) leads to significant increase of the size of Pd particles and the formation of the continuous film

resulting in the significant decrease of the response. All the sensors exhibit the best gas selectivity to H

gas

and the better properties of the response and recovery time and the response stability are obtained. Finally

the influence mechanism of Pd particle surface decoration on the ZnO NW array gas sensors was discussed.

关键词

Keywords

references

CHENG Z M, ZHOU S M, CHEN T Y, et al.. Acetic acid gas sensors based on Ni2+ doped ZnO nanorods prepared by using the solvothermal method[J]. J. Semicond., 2012, 33(11):112003-1-6.

HYODO T, YAMASHITA T, SHIMIZU Y. Effects of surface modification of noble-metal sensing electrodes with Au on the hydrogen-sensing properties of diode-type gas sensors employing an anodized titania film[J]. Sens. Actuators B, 2015, 207:105-116.

GIANCATERINI L, CANTALINI C, CITTADINI M, et al.. Au and Pt nanoparticles effects on the optical and electrical gas sensing properties of sol-gel-based ZnO thin-film sensors[J]. IEEE Sens. J., 2015, 15(2):1068-1076.

LIN Y J, DENG P, NIE Y X, et al.. Room-temperature self-powered ethanol sensing of a Pd/ZnO nanoarray nanogenerator driven by human finger movement[J]. Nanoscale, 2014, 6(9):4604-4610.

李群, 黄金玉, 杜宇, 等. 微波水热法构筑高性能SnO2基乙醇传感器[J]. 深圳大学学报(理工版), 2016, 33(2):147-153. LI Q, HUANG J Y, DU Y, et al.. Highly sensitive ethanol sensor based on SnO2 nanorods synthesized by microwave-assisted hydrothermal method[J]. J. Shenzhen Univ. Sci. Eng., 2016, 33(2):147-153. (in Chinese)

WAHAB R, KHAN F, LUTFULLAH, et al.. Statistical analytical determination of miniature zinc oxide nanoclusters for photodegradation of methylene red dye[J]. Nanosci. Nanotechnol. Lett., 2017, 9(1):1-7.

LIU L, WANG L Y, HAN Y, et al.. Highly sensitive and selective ethanol sensors based on flower-like ZnO nanorods[J]. J. Semicond., 2011, 32(9):092005-1-4.

NAVALE S T, JADHAV V V, TEHARE K K, et al.. Solid-state synthesis strategy of ZnO nanoparticles for the rapid detection of hazardous Cl2[J]. Sens. Actuators B, 2017, 238:1102-1110.

NAVALE S T, TEHARE K K, SHAIKH S F, et al.. Hexamethylenetetramine-mediated TiO2 films:facile chemical synthesis strategy and their use in nitrogen dioxide detection[J]. Mater. Lett., 2016, 173:9-12.

HWANG I S, CHOI J K, WOO H S, et al.. Facile control of C2H5OH sensing characteristics by decorating discrete Ag nanoclusters on SnO2 nanowire networks[J]. ACS Appl. Mater. Interf., 2011, 3(8):3140-3145.

曹培江, 彭双娇, 韩舜, 等. ZnO纳米/微米结构传感器对乙醇气敏性研究[J]. 发光学报, 2014, 35(4):460-464. CAO P J, PENG S J, HAN S, et al.. Gas-sensitive property of nano/micro-structured ZnO sensors on ethanol[J]. Chin. J. Lumin., 2014, 35(4):460-464. (in Chinese)

LI Y, LV T, ZHAO F X, et al.. Polarity-enhanced gas-sensing performance of Au-loaded ZnO nanospindles synthesized via precipitation and microwave irradiation[J]. Electron. Mater. Lett., 2016, 12(3):411-418.

Views

171

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰