Transient Thermal Characteristics of Heat Capacity High Power Diode Lasers

JIA Guan-nan; YAO Shun; GAO Xiang-yu; LAN Tian; QIU Yun-tao; WANG Zhi-yong

doi:10.3788/fgxb20163704.0422

您当前的位置：

首页 >

文章列表页 >

Transient Thermal Characteristics of Heat Capacity High Power Diode Lasers

更新时间：2020-08-12

- Transient Thermal Characteristics of Heat Capacity High Power Diode Lasers
- Chinese Journal of Luminescence Vol. 37, Issue 4, Pages: 422-427(2016)
- 作者机构：
  
  北京工业大学激光工程研究院北京,100124
- 作者简介：
- 基金信息：
- DOI：10.3788/fgxb20163704.0422
  CLC： TN248.4
- Received：24 December 2015，
  
  Revised：17 January 2016，
  
  Published：05 April 2016
- 稿件说明：
移动端阅览
贾冠男, 尧舜, 高祥宇等. 热容型大功率半导体激光器瞬态热特性[J]. 发光学报, 2016,37(4): 422-427

JIA Guan-nan, YAO Shun, GAO Xiang-yu etc. Transient Thermal Characteristics of Heat Capacity High Power Diode Lasers[J]. Chinese Journal of Luminescence, 2016,37(4): 422-427
贾冠男, 尧舜, 高祥宇等. 热容型大功率半导体激光器瞬态热特性[J]. 发光学报, 2016,37(4): 422-427 DOI： 10.3788/fgxb20163704.0422.

JIA Guan-nan, YAO Shun, GAO Xiang-yu etc. Transient Thermal Characteristics of Heat Capacity High Power Diode Lasers[J]. Chinese Journal of Luminescence, 2016,37(4): 422-427 DOI： 10.3788/fgxb20163704.0422.

摘要

为研究热容型大功率半导体激光器在低环境温度、高瞬时功率、长工作间歇时间条件下的应用

建立三维瞬态热传导模型

通过有限元法计算得出热沉三维尺寸对半导体激光器瞬态热特性的影响。选取尺寸为26.6 mm11.5 mm4 mm的热沉进行热容型半导体激光器的封装测试

获得其在-20 ℃和-30 ℃环境温度下连续工作3.5 s过程中有源区温度随时间的变化曲线

并与数值计算的结果进行对比。结果表明

两者在误差范围内能够很好地吻合。

Abstract

To investigate the application of heat capacity high power diode lasers under the condition of low temperature

high transient power and long interval working time

a 3-D transient thermal model was established. By adopting the finite element analysis

the effect of 3-D sizes of the heat sink on the transient thermal characteristics of diode laser was calculated successfully. According to the simulation results

the heat sink with dimension of 26.6 mm11.5 mm4 mm was chosen to package the heat capacity diode laser

and the experiments of the diode laser working 3.5 s continuously under -20 ℃ and -30 ℃ were carried out respectively. Eventually

the temperature curves of the active region were obtained and demonstrated a good consistence with the simulation results.

关键词

Keywords

references

王立军,宁永强,秦莉,等. 大功率半导体激光器研究进展 [J]. 发光学报, 2015, 36(1):1-19. WANG L J, NING Y Q, QIN L, et al.. Development of high power diode laser [J]. Chin. J. Lumin., 2015, 36(1):1-19. (in Chinese)

TIMMERMANN A, MEINSCHIEN J, BRUNS P, et al.. Next generation high-brightness diode lasers offer new industrial applications [J]. SPIE, 2008, 6876:68760U.

马骁宇,王俊,刘素平. 国内大功率半导体激光器研究及应用现状 [J]. 红外与激光工程, 2008, 37(2):189-194. MA X Y, WANG J, LIU S P. Present situation of investigations and applications in high power semiconductor lasers [J]. Infrared Laser Eng., 2008, 37(2):189-194. (in Chinese)

WU M C, OLSSON N A, SIVCO D, et al.. A 970 nm strained-layer InGaAs/GaAlAs quantum well laser for pumping an erbium-doped optical fiber amplifier [J]. Appl. Phys. Lett., 1990, 56(3):221-223.

武斌,李毅,胡双双,等. 非制冷980 nm半导体激光器封装设计与热特性分析 [J]. 中国激光, 2009, 36(4):799-803. WU B, LI Y, HU S S, et al.. Design and thermal characteristics analysis of uncooled 980 nm semiconductor laser packaging [J]. Chin. J. Lasers, 2009, 36(4):799-803. (in Chinese)

王文,高欣,周泽鹏,等. 百瓦级多芯片半导体激光器稳态热分析 [J]. 红外与激光工程, 2014, 43(5):1438-1443. WANG W, GAO X, ZHOU Z P, et al.. Steady-state thermal analysis of hundred-watt semiconductor laser with multichip-packaging [J]. Infrared Laser Eng., 2014, 43(5):1438-1443. (in Chinese)

ROSSIN V, PETER M, ZUCKER E, et al.. Highly reliable high-power broad area laser diodes [J]. SPIE, 2006, 6104:610-407.

WITZIGMANN B, HYBERTSEN M S. A theoretical investigation of the characteristic temperature T0 for semiconductor lasers [J]. IEEE J. Sel. Top. Quant. Electron., 2003, 9(3):807-815.

KOBAYASHI T, FURUKAWA Y. Temperature distributions in the GaAs-AlGaAs double-heterostructure laser below and above the threshold current [J]. Jpn. J. Appl. Phys., 1975, 14(12):1981-1986.

王祥鹏,梁雪梅,李再金,等. 880 nm半导体激光器列阵及光纤耦合模块[J]. 光学精密工程, 2010, 18(5):1021-1027. WANG X P, LIANG X M, LI Z J, et al.. 880 nm semiconductor laser diode arrays and fiber coupling module [J]. Opt. Precision Eng., 2010, 18(5):1021-1027. (in Chinese)

CHIN A K, NELSON A, CHIN R H, et al.. Copper-based micro-channel cooler reliably operated using solutions of distilled-water and ethanol as a coolant [J]. SPIE, 2015, 9348:93480Y.

张志军,刘云,付喜宏,等. 激光二极管合束模块整体散热热阻分析 [J]. 中国激光, 2012, 39(4):0402010-1-5. ZHANG Z J, LIU Y, FU X H, et al.. Analysis on overall thermal resistance of laser diode beam combined modules [J]. Chin. J. Lasers, 2012, 39(4):0402010-1-5. (in Chinese)

VAN DER ZIEL J P, Chand N. High-temperature operation (to 180 ℃) of 0.98 m strained single quantum well In0.2Ga0.8As/GaAs lasers [J]. Appl. Phys. Lett., 1991, 58(13):1437-1439.

鲁鹏程,崔碧峰,李建军,等. 隧道再生大功率半导体激光器瞬态热特性研究 [J]. 中国激光, 2004, 31(5):518-522. LU P C, CUI B F, LI J J, et al.. Transient thermal characteristic analysis of tunnel regeneration high-power semiconductor laser [J]. Chin. J. Lasers, 2004, 31(5):518-522. (in Chinese)

张建伟,宁永强,张星,等. 基于载流子注入产热机制的半导体激光器热模型分析 [J]. 中国激光, 2012, 39(10):1002003-1-8. ZHANG J W, NING Y Q, ZHANG X, et al.. Analysis of thermal model based on the carrier injection mechanisms within the semiconductor laser [J]. Chin. J. Lasers, 2012, 39(10):1002003-1-8. (in Chinese)

张晓波,高鼎三. InP/InGaAsP条形半导体激光器中的瞬态温度特性理论计算 [J]. 半导体学报, 1989, 10(5):362-367. ZHANG X B, GAO D S. Transient thermal effects calculation in InP/InGaAsP stripe geometry semiconductor laser diode [J]. Chin. J. Semiconduct., 1989, 10(5):362-367. (in Chinese)

袁振邦,王警卫,吴迪,等. 大功率半导体激光器阵列的稳态和瞬态热行为 [J]. 中国激光, 2009, 36(8):1957-1962. YUAN Z B, WANG J W, WU D, et al.. Static and transient thermal behavior of high power semiconductor lasers [J]. Chin. J. Lasers, 2009, 36(8):1957-1962. (in Chinese)

Views

209

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Analysis of Coupling Tolerance in Laser Packaging

Continuous-wave Laser Properties of Er∶Lu₂O₃ Crystal Grown by EFG Method

Research Progress of Surface Plasmon Polariton Metal-Insulator-Semiconductor Waveguide Lasers

Research Progress Towards Perovskite Electrical Driven Lasers

Experimental Research on Volume-Bragg-grating External Cavity Red-light Semiconductor Lasers

Related Author

ZHANG Cai

LIU Jiayao

WANG Qingqing

WANG Guiji

LIANG Yangyang

SU Chunyun

JIA Wenzeng

LI Tao

Related Institution

Xinlianxin （Hebei Xiong’an） Technology Co.， Ltd.， Xiongan

Institute of Semiconductor， Chinese Academy of Sciences

School of Intelligent and Electronic Engineering， Dalian Neusoft University of Information

Key Laboratory of Laser & Infrared System（Shandong University）， Ministry of Education

State Key Laboratory of Crystal Materials， Shandong University

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰