Optical and Electrical Properties of AZO/Ag/AZO Transparent Conductive Films Prepared by RF Magnetron Sputtering Using Powder Targets

LIU Si-ning; ZHOU Yan-wen; WU Chuan; WU Fa-yu

doi:10.3788/fgxb20153612.1427

您当前的位置：

首页 >

文章列表页 >

Optical and Electrical Properties of AZO/Ag/AZO Transparent Conductive Films Prepared by RF Magnetron Sputtering Using Powder Targets

更新时间：2020-08-12

- Optical and Electrical Properties of AZO/Ag/AZO Transparent Conductive Films Prepared by RF Magnetron Sputtering Using Powder Targets
- Chinese Journal of Luminescence Vol. 36, Issue 12, Pages: 1427-1433(2015)
- 作者机构：
  
  辽宁科技大学材料与冶金学院,辽宁鞍山,114051
- 作者简介：
- 基金信息：
- DOI：10.3788/fgxb20153612.1427
  CLC： TM24;O484.4
- Received：10 August 2015，
  
  Revised：24 August 2015，
  
  Published：10 December 2015
- 稿件说明：
移动端阅览
刘思宁, 周艳文, 吴川等. 粉末靶制备的AZO/Ag/AZO透明导电薄膜的光电性能[J]. 发光学报, 2015,36(12): 1427-1433

LIU Si-ning, ZHOU Yan-wen, WU Chuan etc. Optical and Electrical Properties of AZO/Ag/AZO Transparent Conductive Films Prepared by RF Magnetron Sputtering Using Powder Targets[J]. Chinese Journal of Luminescence, 2015,36(12): 1427-1433
刘思宁, 周艳文, 吴川等. 粉末靶制备的AZO/Ag/AZO透明导电薄膜的光电性能[J]. 发光学报, 2015,36(12): 1427-1433 DOI： 10.3788/fgxb20153612.1427.

LIU Si-ning, ZHOU Yan-wen, WU Chuan etc. Optical and Electrical Properties of AZO/Ag/AZO Transparent Conductive Films Prepared by RF Magnetron Sputtering Using Powder Targets[J]. Chinese Journal of Luminescence, 2015,36(12): 1427-1433 DOI： 10.3788/fgxb20153612.1427.

摘要

室温下

采用射频磁控溅射AZO粉末靶和Ag靶在玻璃基底上制备Ag层厚度分别为12 nm和15 nm两组对称结构掺铝氧化锌/银/掺铝氧化锌(AZO/Ag/AZO)透明导电薄膜

研究了Ag层和AZO层厚度对薄膜光电性能的影响。结果表明:3层薄膜的可见光区平均透光率达到了80%

550 nm处的最高透过率达到了88%

方块电阻小于5 /□。Ag层厚度是影响AZO/Ag/AZO薄膜光电性能的主要因素

AZO层的厚度对薄膜光学性能影响较大。

Abstract

The sandwich films composed of aluminum doped zinc oxide (AZO)/silver (Ag)/aluminum doped zinc oxide (AZO) layers were prepared on glass substrates by RF magnetron sputtering using AZO powder target and solid Ag target at room temperature. Two groups of AZO/Ag/AZO films were deposited with Ag thickness of 12 nm and 15 nm. The optical and electrical properties of the sandwich films were investigated. The results show that the average transmittance of the films are about 80% within the visible wavelength

and the highest transmittance is 88% at 550 nm. The sheet resistances of the multilayer films are lower than 5 /□. The thickness of Ag layer is the main factor to affect the optical and electrical properties of AZO/Ag/AZO films. The thickness of AZO layer has a certain effect on the optical properties of the sandwich films.

关键词

Keywords

references

Li J M, Cai X, Mao Y F. TiO2/Ag/TiO2 nano-multilayer [J]. Mater. Mechan. Eng.(机械工程材料), 2004, 28(2):34-37 (in Chinese).

Zuo J, Guo X Y, Liu X Y. V2O5/Ag/V2O5 multilayer transparent conductive films based on sol-gel and electron beam evaporation techniques [J]. Chin. J. Lumin.(发光学报), 2014, 35(3):360-365 (in Chinese).

Cai X. Progress in research of the adjustable transparent conducting multilayers [J]. J. Funct. Mater.(功能材料), 2007, 38(S1):1-3 (in Chinese).

Wang Z G, Cai X. Progress in research of metal-based compound transparent conducting multilayers [J]. Mater. Mechan. Eng.(机械工程材料), 2005, 29(2):1-3 (in Chinese).

Guo M X. Preparation and characterization of Al-Ti co-doped zinc oxide films [J]. Chin. J. Liq. Cryst. Disp.(液晶与显示), 2011, 26(2):161-164 (in Chinese).

Fang R C. Solid State Spectroscopy [M]. Hefei: University of Science and Technology of China Press, 2001:26 (in Chinese).

Tang Y, Guo L D, Zhang Z G, et al. Aluminum doping and optical property control of electrodeposited zinc oxide nanorods induced by ammonium nitrate [J]. Opt. Precision Eng.(光学精密工程), 2015, 23(5):1288-1296 (in Chinese).

Shen D Z, Mei Z X, Liang H L, et al. ZnO-based material, heterojunction and photoelctronic device [J]. Chin. J. Lumin.(发光学报), 2014, 35(1):1-60 (in Chinese).

Shi S J, Zhu D L, Lv Y M, et al. Effects of post-annealing in Ar atmosphere on the electrical properties of HAZO films [J]. Chin. J. Lumin.(发光学报), 2012, 33(7):742-746 (in Chinese).

Ando E, Miyazaki M. Moisture resistance of the low-emissivity coatings with a layer structure of Al-doped ZnO/Ag/Al-doped ZnO [J]. Thin Solid Films, 2001, 392(2):289-294.

Ando E, Miyazaki M. Moisture degradation mechanism of silver-based low-emissivity coatings [J]. Thin Solid Films, 1999, 351(1-2):308-313.

Lv K, Zhu B L, Li K, et al. Effect of hydrogen and Cu interlayer on the optical and electrical properties of GZO thin film [J]. J. Inorg. Mater.(无机材料学报), 2014, 29(5):493-497 (in Chinese).

Yu S H, Ding L H, Xue C, et al. Influence of O2/Ar ration on the properties of transparent conductive SnO2/Ag/SnO2 trilayer film [J]. Acta Photon. Sinica (光子学报), 2012, 41(9):1086-1089 (in Chinese).

Kelly P J, Zhou Y W. Zinc oxide-based transparent conductive oxide films prepared by pulsed magnetron sputtering from powder targets: Process features and film properties [J]. J. Vac. Sci. Technol.A, 2006, 24(5):1782-1789.

Kelly P J, Zhou Y W, Postill A. A novel technique for the deposition of aluminium-doped zinc oxide films [J]. Thin Solid Films, 2003, 426(1/2):111-116.

Kelly P J, Zhou Y W, Postill A, et al. The characteristics of aluminium-doped zinc oxide films prepared by pulsed magnetron sputtering from powder targets [J]. Thin Solid Films, 2004, 447/448(1):33-39.

Wendt R, Ellmer K. Desorption of Zn from a growing ZnO:Al films deposited by magnetron sputtering [J]. Surf. Coating Technol., 1997, 93(1):27-31.

Wendt R, Ellmer K. DC and RF (reactive) magnetron sputtering of ZnO:Al films form metallic and ceramic target: A comparative study [J]. Surf. Coating Technol., 1997, 93(1):21-26.

Ellmer K. Influence of discharge parameters on the layer properties of reactive by magnetron sputtered ZnO:Al films of Zn from a growing ZnO:Al films [J]. Thin Solid Films, 1994, 247(1):15-23.

Liu J, Liu D, Gu Z A. Research progress of D/M/D transparent conductive multilayer films [J]. Mater. Rev.(材料导报), 2005, 19(8):9-12 (in Chinese).

Jiang X, Sun C, Rui H J, et al. Transparent Conductive Oxide Films [M]. Beijing: Higher Education Press, 2008:5-6 (in Chinese).

Lu J J, Liu W G. Optical Thin Film Technology [M]. Xi'an: Northwestern Polytechnical University Press, 2005:16-27 (in Chinese).

Jia F, Qiao X L, Chen J G, et al. Research on metal-based compound transparent conducting multilayer films [J]. Chin. J. Rare met.(稀有金属), 2006, 30(4):505-509 (in Chinese).

Lin Y Q, Feng S M, Wang K X, et al. Effects of film thickness less than electrical mean free path on reflectivity [J]. Acta Photon. Sinica (光子学报), 2011, 40(2):263-265 (in Chinese).

Views

186

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Properties of ZnO/Ag/ZnO Transparent Conducting Thin Films Prepared by Magnetron Sputtering

Effect of Sputtering Temperature on Microstructural and Optical Properties of Gallium Oxide Deposited by High-vacuum Magnetron Sputtering

Fabrication and Electrical and Optical Properties of Nitrogen-doped In-Sn-Zn Oxide Thin-film Transistors

Structural and Optical Properties of SnS₂ Films Prepared by RF Magnetron Sputtering

Structural and Optical Properties of SnS Films Prepared by RF Magnetron Sputtering

Related Author

LI Tong

ZHOU Yan-wen

WANG Yan-xue

ZHAO Zhuo

WU Jun-sheng

GAO Peng

WANG Xiao-ming

YANG Wei-jia

Related Institution

State Key Laboratory of Metal Materials and Applications for Marine Equipment, Angang Iron and Steel Research Institute, Anshan Iron and Steel Group

Institute of Surface Engineering, University of Science and Technology Liaoning

School of Chemistry Engineering, University of Science and Technology Liaoning

Ukraine Institute of Welding， Guangdong Academy of Sciences

School of Applied Physics and Materials， Wuyi University

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰