Superhydrophobic Drag Reduction Characteristics of The Surface of Micro-nano Hierarchical ZnO Structure

WU Chun-xia; Song Xing; HE Zi-juan; SUN Qing-feng

doi:10.3788/fgxb20153611.1330

您当前的位置：

首页 >

文章列表页 >

Superhydrophobic Drag Reduction Characteristics of The Surface of Micro-nano Hierarchical ZnO Structure

更新时间：2020-08-12

- Superhydrophobic Drag Reduction Characteristics of The Surface of Micro-nano Hierarchical ZnO Structure
- Chinese Journal of Luminescence Vol. 36, Issue 11, Pages: 1330-1334(2015)
- 作者机构：
  
  江苏大学材料科学与工程学院, 江苏镇江 212013
- 作者简介：
- 基金信息：
- DOI：10.3788/fgxb20153611.1330
  CLC： O484.4
- Received：10 September 2015，
  
  Revised：05 October 2015，
  
  Published：10 November 2015
- 稿件说明：
移动端阅览
吴春霞, 宋刑, 何自娟等. 微纳跨尺度结构ZnO表面的壁面减阻特性[J]. 发光学报, 2015,36(11): 1330-1334

WU Chun-xia, Song Xing, HE Zi-juan etc. Superhydrophobic Drag Reduction Characteristics of The Surface of Micro-nano Hierarchical ZnO Structure[J]. Chinese Journal of Luminescence, 2015,36(11): 1330-1334
吴春霞, 宋刑, 何自娟等. 微纳跨尺度结构ZnO表面的壁面减阻特性[J]. 发光学报, 2015,36(11): 1330-1334 DOI： 10.3788/fgxb20153611.1330.

WU Chun-xia, Song Xing, HE Zi-juan etc. Superhydrophobic Drag Reduction Characteristics of The Surface of Micro-nano Hierarchical ZnO Structure[J]. Chinese Journal of Luminescence, 2015,36(11): 1330-1334 DOI： 10.3788/fgxb20153611.1330.

摘要

通过化学气相沉积方法获得了具有良好超疏水特性的微纳跨尺度结构ZnO表面

其表面接触角为150.7.扫描电镜(SEM)的测试结果表明

样品结构为ZnO微米柱阵列和在上面交织生长的高密度ZnO针状纳米线的复合结构.通过流变仪

采用分步流动模式对样品表面在不同的剪切速率和不同间距的情况下进行测量

得到了扭矩与剪切速率之间的关系.进一步选择覆盖硅烷的光滑Si表面作为对比样品

选用40％的甘油作为试验液体

当剪切速率接近20 s

-1

时

测试的表面滑移长度为46.8 m.这表明微纳跨尺度结构的ZnO表面可有效增加流体减阻特性

有利于制备具有减阻效应的微器件.

Abstract

Micro-nano hierarchical ZnO structures with superhydrophobic surfaces were synthesized by chemical vapor deposition. The contact angle of the water droplet on the sample surface was 150.7. The sample structure of micro-column array with nanoneedles on top was confirmed by SEM. By using the AR-G2 Rheometer with step-by-step measurement mode

the relationship between torque and shear rate was obtained by varying the shear rates and spacing. Smooth silicon surface with silane on top and 40% glycerol were used as comparison. The slip length of the surface was 46.8 m when the shear rate was 20 s

-1

. This indicates that the surface of micro-nano hierarchical ZnO structures is beneficial to increasing the drag properties of the liquid.

关键词

Keywords

references

Choi C H, Kim C J. Measurement of liquid slip on nanoturf surfaces [C]//Integrated Nanosystems Design, Synthesis & Applications, Berkeley: ASME, 2005:59-60.

Choi C H, Kim C J. Large slip of aqueous liquid flow over a nanoengineered superhydrophobic surface [J]. Phys. Rev. Lett., 2006,96(6):066001-1-5.

Ou J, Rothstein J P. Direct velocity measurements of the flow past drag-reducing ultrahydrophobic surfaces [J]. Phys. Fluids, 2005, 17(10):103606-1-6.

Ou J, Perot B, Rothstein J P. Laminar drag reduction in microchannels using ultrahydrophobic surfaces [J]. Phys. Fluids, 2004, 16:4635-4639.

Watanabe K, Yanuar, Udagawa H. Drag reduction of newtonian fluid in a circular pipe with a highly water-repellent wall [J]. J. Fluid Mech., 1999, 381:225-229.

Pit R, Hervet H, Lger L. Direct experimental evidence of slip in hexadecane: Solid interfaces [J]. Phys. Rev. Lett., 2000, 85:980-985.

Huang P, Guasto J, Breuer K. Direct measurement of slip velocities using three-dimensional total internal reflection velocimetry [J]. J. Fluid Mech., 2006, 566:465-475.

Min T, Kim J. Effects of hydrophobic surface on skin-friction drag [J]. Phys. Fluids, 2005, 16:L55-L59.

Kang S, Choi H. Active wall motions for skin-friction drag reduction [J]. Phys. Fluids, 2000, 12:3301-3305.

Choi C H, Westin K J A, Breuer K S. Apparent slip flows in hydrophilic and hydrophobic microchannels [J]. Phys. Fluids, 2003, 15:2897-2902.

Sirovich L, Karlsson S. Turbulent drag reduction by passive mechanisms [J]. Nature, 1997, 388:753-757

Choi C H, Ulmanella U, Kim J W, et al. Effective slip and friction reduction in nanograted superhydrophobic microchannels [J]. Phys. Fluids, 2006, 18(8):087105-1-5.

Joseph P, Cottin-Bizonne C, Benoit J M, et al. Slippage of water past superhydrophobic carbon nanotube forests in microchannels [J]. Phys. Rev. Lett., 2006, 97(15):156104-1-6.

Srinivasan S, Choi W, Park K C, et al. Drag reduction for viscous laminar flow on spray-coated non-wetting surfaces [J]. Soft Matter, 2013, 9:5691-5696.

Lee C, Kim C J. Influence of surface hierarchy of superhydrophobic surfaces on liquid slip [J]. Langmuir, 2011, 27:4243-4249.

Views

148

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Responsivity Characteristics of ZnO Schottky Ultraviolet Photodetectors with High Gain

ZnO Luminescence Behavior Under Low Temperature by Ion-beam-induced Luminescence

Effect of Growth Temperature on Epitaxial ZnO Nanostructures by MOCVD

Influence of ZnO on Luminescent Properties of CdS_xSe_1-x Quantum Dot Silicate Glass

Controllable Growth of High Quality ZnO Thin Film on c-sapphire

Related Author

DUAN Yuhan

JIANG Dayong

ZHAO Man

Guo-qiang ZHAO

Jin-fu ZHANG

Guang-fu WANG

Meng-lin QIU

Ting-shun WANG

Related Institution

School of Materials Science and Engineering， Changchun University of Science and Technology

Engineering Research Center of Optoelectronic Functional Materials， Ministry of Education

Key Laboratory of Beam Technology of Ministry of Education, College of Nuclear Science and Technology, Beijing Normal University

Beijing Radiation Center

State Key Laboratory of Integrated Optoelectronics, College of Electronic Science and Engineering, Jilin University

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰