Preparation of AZO/Ag/AZO Transparent Conductive Films Deposited on Glass and Polyimide Substrates Using Powder Targets

LIU Si-ning; ZHOU Yan-wen; SHA Tian-yi

doi:10.3788/fgxb20153611.1300

您当前的位置：

首页 >

文章列表页 >

Preparation of AZO/Ag/AZO Transparent Conductive Films Deposited on Glass and Polyimide Substrates Using Powder Targets

更新时间：2020-08-12

- Preparation of AZO/Ag/AZO Transparent Conductive Films Deposited on Glass and Polyimide Substrates Using Powder Targets
- Chinese Journal of Luminescence Vol. 36, Issue 11, Pages: 1300-1306(2015)
- 作者机构：
  
  辽宁科技大学材料与冶金学院,辽宁鞍山,114051
- 作者简介：
- 基金信息：
- DOI：10.3788/fgxb20153611.1300
  CLC： TM24;O484.4
- Received：04 August 2015，
  
  Revised：24 September 2015，
  
  Published：10 November 2015
- 稿件说明：
移动端阅览
刘思宁, 周艳文, 沙天怡. 用粉末靶在玻璃和PI衬底上制备AZO/Ag/AZO薄膜[J]. 发光学报, 2015,36(11): 1300-1306

LIU Si-ning, ZHOU Yan-wen, SHA Tian-yi. Preparation of AZO/Ag/AZO Transparent Conductive Films Deposited on Glass and Polyimide Substrates Using Powder Targets[J]. Chinese Journal of Luminescence, 2015,36(11): 1300-1306
刘思宁, 周艳文, 沙天怡. 用粉末靶在玻璃和PI衬底上制备AZO/Ag/AZO薄膜[J]. 发光学报, 2015,36(11): 1300-1306 DOI： 10.3788/fgxb20153611.1300.

LIU Si-ning, ZHOU Yan-wen, SHA Tian-yi. Preparation of AZO/Ag/AZO Transparent Conductive Films Deposited on Glass and Polyimide Substrates Using Powder Targets[J]. Chinese Journal of Luminescence, 2015,36(11): 1300-1306 DOI： 10.3788/fgxb20153611.1300.

摘要

室温下在玻璃和聚酰亚胺两种不同衬底上

采用射频磁控溅射法溅射掺铝氧化锌(AZO)粉末靶和固体Ag靶

制备了两组AZO/Ag/AZO 3层透明导电薄膜

研究了AZO层厚度对不同衬底3层膜结构和光电性能的影响.结果表明:不同衬底的两组AZO/Ag/AZO薄膜均为多晶膜.当Ag层厚度不变时

随着AZO层厚度的增加

两组薄膜电学性能变化不大

透射峰向长波方向移动.玻璃和PI衬底上制备的AZO(30 nm)/Ag(14 nm)/AZO(30 nm)薄膜

在550 nm处的透光率分别为85%和70%

方块电阻分别为2.6 /□和4.6 /□.

Abstract

The sandwich films composed of aluminum ions doped zinc oxide (AZO)/silver(Ag)/AZO films were prepared on polyimide (PI) and glass substrates by RF magnetron sputtering using the powder AZO target and the solid Ag target at room temperature. The effect of the thicknesses of AZO layers on the structure

optical and electrical properties of the sandwich films was investigated. The results show that the as-deposited films are polycrystalline on both PI and glass substrates. The changes of the electrical properties of the sandwich films are not obvious

and the positions of the highest transmittance shift towards the long wavelength region with the increasing of AZO thickness. When the thicknesses of the films are 30 nm of AZO and 14 nm of Ag

the sheet resistances are as low as 2.6 /□ and 4.6 /□ on glass and PI substrates

respectively. The transmittances of the films at 550 nm are 85% on glass and 70% on PI substrates.

关键词

Keywords

references

Zhang F, Tao J, Dong X. Development and preparation of flexible transparent conductive film [J]. Mater. Rev.(材料导报), 2007, 21(3):119-122 (in Chinese).

Zhuang T J, Su Z S, Liu Y D, et al. Enhanced performance of small molecular weight organic solar cells by incorporating Ag nanoparticles [J]. Chin. J. Lumin.(发光学报), 2011, 32(12):1266-1270 (in Chinese).

Li R R, Zhao J J, Si H Y, et al. Development of flexible thin film solar cells [J]. J. Chin. Ceram. Soc.(硅酸盐学报), 2014, 42(7):878-883 (in Chinese).

He W F, Zhao Y T, Li S M, et al. Preparation methods and development prospect of flexible transparent conductive films [J]. Mater. Rev.(材料导报), 2005, 19(3):32-36 (in Chinese).

Guo L, Zhao D X, Zhang Z Z, et al. Optoelectronic properties of ZnO/Ag/ZnO multiple films [J]. Chin. J. Lumin.(发光学报), 2011, 32(9):920-923 (in Chinese).

Guo M X. Preparation and characterization of Al-Ti co-doped zinc oxide films [J]. Chin. J. Liq. Cryst. Disp.(液晶与显示), 2011, 26(2):161-164 (in Chinese).

Zuo J, Guo X Y, Liu X Y. V2O5/Ag/V2O5 multilayer transparent conductive films based on sol-gel and electron beam evaporation techniques [J]. Chin. J. Lumin.(发光学报), 2014, 35(3):360-365 (in Chinese).

Cai X, Wang Z G. Progress and trend in study on the transparent conducting films [J]. J. Funct. Mater.(功能材料), 2004, 35(S1):76-81 (in Chinese).

Fang R C. Solid State Spectroscopy [M]. Hefei: University of Science and Technology of China Press, 2001:26 (in Chinese).

Zhou Y W, Kelly P J, Sun Q B. The characteristics of the plasma in a powder sputtering rig [J]. Thin Solid Films, 2008, 516(12):4030-4035.

Kelly P J, Zhou Y W. Zinc oxide-based transparent conductive oxide films prepared by pulsed magnetron sputtering from powder targets: Process features and film properties [J]. J. Vac. Sci. Technol. A, 2006, 24(5):1782-1789.

Zhou Y W, Liu Y, Wu F Y, et al. The characteristics of CdxSn1-xO films prepared by RF magnetron sputtering from powder targets [J]. Surf. Coatings Technol., 2013, 228(S1):S150-S154.

Kelly P J, Zhou Y W, Postill A. A novel technique for the deposition of aluminium-doped zinc oxide films [J]. Thin Solid Films, 2003, 426(1-2):111-116.

Kelly P J, Zhou Y W, Postill A, et al. The characteristics of aluminium-doped zinc oxide films prepared by pulsed magnetron sputtering from powder targets [J]. Thin Solid Films, 2004, 447(4):33-39.

Wendt R, Ellmer K. Desorption of Zn from a growing ZnO :Al films deposited by magnetron sputtering [J]. Surf. Coating Technol., 1997, 93(1):27-31.

Wendt R, Ellmer K. DC and RF (reactive) magnetron sputtering of ZnO :Al films form metallic and ceramic target: A comparative study [J]. Surf. Coating Technol., 1997, 93(1):21-26.

Ellmer K. Influence of discharge parameters on the layer properties of reactive by magnetron sputtered ZnO :Al films of Zn from a growing ZnO :Al films [J]. Thin Solid Films, 1994, 247(1):15-23.

Qin X Y. Thermal expansion behavior of nanocrystalline of Ag at high temperatures [J]. Acta Phys. Sinica (物理学报), 1995, 44(2):244-250 (in Chinese).

Li X K, Li Q S, Liang D C, et al. Effect of Ag growth temperature on the Ag/ZnO schottky contact characteristics [J]. Sci. China Ser. E: Tech.(中国科学E辑:技术科学), 2009, 39(7):1269-1274 (in Chinese).

Cai X. Progress in research of the adjustable transparent conducting multilayers [J]. J. Funct. Mater.(功能材料), 2007, 38(S1):1-3 (in Chinese).

Liu J, Liu D, Gu Z A. Research progress of D/M/D transparent conductive multilayer films [J]. Mater. Rev.(材料导报), 2005, 19(8):9-12 (in Chinese).

Jiang X, Sun C, Rui H J, et al. Transparent Conductive Oxide Films [M]. Beijing: Higher Education Press, 2008:5-6 (in Chinese).

Lu J J, Liu W G. Optical Thin Film Technology [M]. Xi'an: Northwestern Polytechnical University Press, 2005:16-27 (in Chinese).

Jia F, Qiao X L, Chen J G, et al. Research on metal-based compound transparent conducting multilayer films [J]. Chin. J. Rare Met.(稀有金属), 2006, 30(4):505-509 (in Chinese).

Bender M, Seelig W, Daube C, et al. Dependence of film composition and thicknesses on optical and eletrical properties of ITO-metal-ITO multilayers [J]. Thin Solid Films, 1998, 326(1-2):67-71.

Zhang H, Shen H L, Lu L F, et al. Effect of working pressure on properties of flexible AZO thin films deposited by room temperature sputtering [J]. J. Funct. Mater.(功能材料), 2010, 41(7):1154-1157 (in Chinese).

Views

202

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

(002) Preferred Oriented AlN Films Grown by DC Magnetron Sputtering and Photoluminescence

Fabrication of Cu₂SnS₃ Thin Films Solar Cells by Magnetron Sputtering Sn and CuS Targets

Preparation of ZnO Thin Film on Zein by RF Magnetron Sputtering

Properties of ZnO/Ag/ZnO Transparent Conducting Thin Films Prepared by Magnetron Sputtering

Mo/Cu Source/Drain Electrodes for Amorphous InGaZnO Thin Film Transistors

Related Author

LYU Wei

LIU Jun

ZHAO Peng-yu

LI Jian-liang

LI Si-da

SHEN Long-hai

XU Xin

WANG Shu-rong

Related Institution

School of Science, Shenyang Ligong University

Yunnan Key Laboratory of Opto-electronic Information Technology, Key Laboratory of Rural Energy Engineering in Yunnan, Yunnan Normal University

吉林建筑大学电气与计算机学院

吉林建筑大学吉林省建筑电气综合节能重点实验室

State Key Laboratory of Metal Materials and Applications for Marine Equipment, Angang Iron and Steel Research Institute, Anshan Iron and Steel Group

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰