Fabrication of Amorphous Indium Gallium Zinc Oxide Thin Film Transistor at Low Temperature by RF Magnetron Sputtering

XIN En-long; LI Xi-feng; CHEN Long-long; SHI Ji-feng; LI Chun-ya; ZHANG Jian-hua

doi:10.3788/fgxb20123310.1149

您当前的位置：

首页 >

文章列表页 >

Fabrication of Amorphous Indium Gallium Zinc Oxide Thin Film Transistor at Low Temperature by RF Magnetron Sputtering

更新时间：2020-08-12

- Fabrication of Amorphous Indium Gallium Zinc Oxide Thin Film Transistor at Low Temperature by RF Magnetron Sputtering
- Chinese Journal of Luminescence Vol. 33, Issue 10, Pages: 1149-1152(2012)
- 作者机构：
  
  上海大学新型显示技术及应用集成教育部重点实验室上海,200072
- 作者简介：
- 基金信息：
- DOI：10.3788/fgxb20123310.1149
  CLC： TN321+.5
- Received：05 June 2012，
  
  Revised：01 August 2012，
  
  Published：10 October 2012
- 稿件说明：
移动端阅览
信恩龙, 李喜峰, 陈龙龙, 石继锋, 李春亚, 张建华. 射频磁控溅射低温制备非晶铟镓锌氧薄膜晶体管[J]. 发光学报, 2012,(10): 1149-1152

XIN En-long, LI Xi-feng, CHEN Long-long, SHI Ji-feng, LI Chun-ya, ZHANG Jian-hua. Fabrication of Amorphous Indium Gallium Zinc Oxide Thin Film Transistor at Low Temperature by RF Magnetron Sputtering[J]. Chinese Journal of Luminescence, 2012,(10): 1149-1152
信恩龙, 李喜峰, 陈龙龙, 石继锋, 李春亚, 张建华. 射频磁控溅射低温制备非晶铟镓锌氧薄膜晶体管[J]. 发光学报, 2012,(10): 1149-1152 DOI： 10.3788/fgxb20123310.1149.

XIN En-long, LI Xi-feng, CHEN Long-long, SHI Ji-feng, LI Chun-ya, ZHANG Jian-hua. Fabrication of Amorphous Indium Gallium Zinc Oxide Thin Film Transistor at Low Temperature by RF Magnetron Sputtering[J]. Chinese Journal of Luminescence, 2012,(10): 1149-1152 DOI： 10.3788/fgxb20123310.1149.

摘要

利用射频磁控溅射技术室温制备了铟镓锌氧(IGZO)薄膜

采用X射线衍射(XRD)表征薄膜的晶体结构

原子力显微镜(AFM)观察其表面形貌

分光光度计测量其透光率。结果表明:室温制备的IGZO薄膜为非晶态且薄膜表面均匀平整

可见光透射率大于80%。将室温制备的IGZO薄膜作为有源层

在低温(＜200℃)条件下成功地制备了铟镓锌氧薄膜晶体管(a-IGZOTFT)

获得的a-IGZO-TFT器件的场效应迁移率大于6.0cm

·V

-1

·s

-1

开关比约为10

阈值电压为1.2V

亚阈值摆幅(

)约为0.9V/dec

偏压应力测试a-IGZOTFT阈值电压随时间向右漂移。

Abstract

The indium gallium zinc oxide (IGZO) thin films were fabricated by RF magnetron sputtering at room temperature in this paper.The crystal structure

surface morphology

and optical electrical of the IGZO films were investigated by X-ray diffraction (XRD)

atom force microscopy (AFM)

and photometry

respectively.The results revealed that the IGZO film was amorphous

the surface of the films was uniform and smooth.A good optical transmittance of over 80% was obtained in the visible light.The IGZO thin film transistors were successfully fabricated at low temperature (＜200℃) using the room temperature sputtering IGZO thin film as the active layer.The field effect mobility of a-IGZO TFT was larger than 6.0 cm

·V

-1

·s

-1

.The device's on/off ratio was 10

threshold voltage was 1.2 V and subthreshold voltage swing is 0.9 V/dec.Constant bias stress testing showed that the a-IGZO TFT threshold voltage exhibited positive shifts as time increased.

关键词

Keywords

references

Nomural K,Ohta H,Takagi A,et al.Room-temperature fabrication of trans-parent flexible thin-film transistors using amorphous oxide semiconductors [J]. Nature,2004,432(7016):488-492.

Wager J F.Transparent electronics [J]. Science, 2003,300(5623):1245-1246.

Yabuta H,Sano M,Abe K,et al.High mobility thin film transistor with amorphous InGaZnO4 channel fabricated by room temperature RF-magnetron sputtering [J]. Appl.Phys.Lett., 2006,89(11):112123-1-3.

Kang D,Lim H,Kim C,et al.Amorphous gallium indium zinc oxide thin film transistors:Sensitive to oxygen molecules [J]. Appl.Phys.Lett.,2007,90(19):192101-1-3.

Lee J M,Cho I T,Lee J H,et al.Bias-stress-induced stretched-exponential time dependence of threshold voltage shift in InGaZnO thin film transistors [J]. Appl.Phys.Lett.,2008,93(9):093504-1-4.

Lee J,Park J S,Pyo Y S,et al.The influence of the gate dielectrics on threshold voltage instability in amorphous indium-gallium-zinc oxide thin film transistors [J]. Appl.Phys.Lett., 2009,95(12):123502-1-3.

Sato A,Abe K,Hayashi R,et al.Amorphous In-Ga-Zn-O coplanar homojunction thin film transistor [J]. Appl.Phys.Lett.,2009,94(13):133502-1-3.

Sung S Y,Choi J H,Han U B,et al.Effects of ambient of atmosphere on the transfer characteristics and gate-bias stress stability of amorphous indium-gallium-zinc oxide thin-film transistors [J]. Appl.Phys.Lett., 2010,96(10):102107-1-3.

Suresh A,Muth J F.Bias stress stability of indium gallium zinc oxide channel based transparent thin film transistors [J]. Appl.Phys.Lett., 2008,92(3):033502-1-3.

Sato A,Abe K,Hayashi R,et al.Amorphous In-Ga-Zn-O coplanar homojunction thin-film transistor [J]. Appl.Phys.Lett.,2009,94(13):133502-1-3.

Li J,Zhou F,Lin H P,et al.Effect of N2O plasma treatment on the SiNx-based InGaZnO thin film transistors [J]. Chin.J.Lumin.(发光学报),2012,33(4):400-404 (in Chinese).

Kamiya T,Nomura K,Hosono H.Present status of amorphous In-Ga-Zn-O thin-film transistors [J]. Adv.Mater.,2010,11(4):044305-1-5.

Cross R,de Souza M.Investigating the stability of zinc oxide thin film transistors [J]. Appl.Phys.Lett.,2006,89(26):263513-1-3.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Optimal Design of Thin Film Transistor in Luminescent Film Deposition Technology

Preparation and Properties of Flexible Thin Film Transistors with Si-incorporated SnO₂ Active Layer

Nonlinear Injection Model of Organic Field Effect Transistors

Electrical Properties of Si-doped ZnO-based Thin-film Transistor with Dual-active-layer Structure

Simulation of Amorphous-InGaZnO Thin Film Transistors Driven OLED Pixel Circuit

Related Author

HOU Yi-man

LIU Yang-hui

LIU Lin-lin

LIANG Yi-qian

ZHU Xiao-ke

LI Xiao-qing

ZHANG Jian-dong

LIU Xian-zhe

Related Institution

School of Materials Science and Engineering, South China University of Technology, Guangzhou 510640, China

State Key Laboratory of Luminescence Materials and Devices, South China University of Technology, Guangzhou 510640, China

Institute of Polymer Optoelectronic Materials and Devices, State Key Laboratory of Luminescent Materials and Devices, South China University of Technology

Institute of Microelectronics, School of Physical Science and Technology, Lanzhou University, Lanzhou 730000, China

College of Optical and Electronic Technology, China Jiliang University, Hangzhou 310018, China

AI问答

Address：No.3888 Dong Nanhu Road, Changchun, Jilin, China Postal code：130033
Tel：0431-86176862 Email：fgxbt@126.com
Technical support is provided by Beijing Founder electronics co., LTD 吉ICP备11002662号-17 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰